2005 Toyota Camry - 121,000 Miles - Gray Color on 2040-cars

Auto blog

How to fix a $4,000 hybrid battery problem with vinegar and baking soda

This is one of those 'Don't try this at home if you don't know what you're doing' DIY tales. Two weeks after imgur user "scoodidabop" bought a used Toyota Camry Hybrid with no warranty, he got the Christmas Tree dash display with warnings like "Check VSC System," "Check Hybrid System," and the Check Engine light. After some Internet sleuthing he figured it could be a faulty brake actuator, assuming the hybrid system warning was a false alarm. But it wasn't the actuator, it was the battery, a Toyota dealer telling him that his battery had "gone bad," and he'd need $4,457 to replace it. Then he had a brainstorm: it could be one of the cells that's gone bad, not the whole battery. Scoodidabop has some experience as an electrician, so he figured he could test it and replace any bad cells for about $45 apiece. He removed the battery unit from the trunk and over the course of two hours tested all 68 cells four times. He found nothing wrong. So he devised another type of test and checked every cell again. He couldn't find a problem with any of them. Turns out the problem wasn't in the cells, but with the dirty and corroded copper connectors at the ends of the high-voltage cables. He pulled the 34 connectors and their steel nuts, soaked them in vinegar, gave them a light steel wool scrub, soaked them in baking soda and water to counteract the vinegar, applied an anticorrosive and reinstalled them. That took an hour. When he replaced the battery, the warning lights had all gone out and the battery worked perfectly. Skill level: experience. Cost: less than $10. Perhaps it's time for hybrids to be able to test their own cells individually. Dealers, too.

Senator pushes for up to life sentence for auto execs found to delay recalls

Democratic Senator Claire McCaskill (shown above) has had it with automotive execs stalling when it comes to recalls. The Missiourian has proposed a new bill, the Motor Vehicle and Highway Safety Enhancement Act, which aims to improve the automotive safety following the high-profile fiascos involving General Motors and Toyota. Aside from a doubling of the budget for the National Highway Traffic Safety Administration over the next six years and the removal of the $35-million limit for fining automakers, the plan includes a provision that would punish auto executives if it's discovered they knowingly delayed recalls. How will it punish them, you ask? Oh, you know, just life in prison. The bill "gives federal prosecutors greater discretion to bring criminal prosecutions for auto safety violations and increases the possible penalties, including up to life in prison for violations that result in death," McCaskill's office told The Detroit News. If a delayed recall led to serious injuries, meanwhile, execs could still face a 15-year stint behind bars. As for that change in the fine structure for automakers, the removal of the limit is complemented by a hefty increase in the per-vehicle fine, from $5,000 to $25,000. With this change, GM could have been on the hook for $55 billion (with a "b") in fines for its bumbling of the ignition switch recall, rather than just $35 million. The News says, though, that NHTSA has "wide discretion" in handing out the fines. Considering a $55-billion fine is enough to sink any automaker, it is unlikely that such a monumental sum would be handed out. Still, the potential threat of such a death sentence should be enough for any automaker to sit up and take notice. "With millions of Americans behind the wheel every day, and more than 33,000 killed on our roads each year, we've got to do more to keep our cars and the roads we drive them on safe," McCaskill said, according to The News. "Painful recent examples at Toyota and GM have shown us we also must make it easier to hold accountable those who jeopardize consumers' safety. For too long, auto safety resources have remained virtually stagnant while cars and the safety challenges they present have become more complex." What do you think? Do you agree with McCaskill's proposed bill? Should the punishments for automakers and execs be more or less harsh? Have your say in Comments. News Source: The Detroit NewsImage Credit: J.

Toyota reaches $1.2B unintended acceleration settlement in criminal probe

UPDATE: Just like that, Toyota has released an official statement confirming its $1.2-million dollar settlement with the US Attorney's Office. Our story has been updated to reflect this development and the automaker's official statement has been added below.
Toyota has reached a settlement over the criminal probe into its unintended acceleration problems, and the outcome is more expensive than first expected. The Japanese automaker has agreed to pay $1.2 billion to close the investigation among other settlement terms. The criminal inquiry focused on whether the company kept information from regulators and how it handled drivers' complaints about the problems, according to the sources.
Between 2009 and 2010, Toyota ended up recalling over 10 million vehicles worldwide over sudden acceleration fears. Fixes include modifying floor mats, gas pedals, and installing brake override software on affected models. In addition, Toyota made the latter standard on all of its new vehicles.