Mallett Sky Ls2 on 2040-cars

Auto blog

Junkyard Gem: 2004 Saturn Vue with manual transmission

GM's Saturn Division has been gone since the final 2010 Auras, Outlooks, Skies, and Vues slunk apologetically out of the showrooms, and I'm doing my best to document the more interesting models from The General's once-revolutionary brand. Some of the later Saturns began life as Opel designs, but the Vue actually was the first vehicle to go on the all-new GM Theta platform; the Opel Antara was thus a Saturn copy, a fact that Saturn fans no doubt trot out when they get shamed by Opel zealots over the Astra. Today's Junkyard Gem is a most unusual Vue, in the sense that its original purchaser was fine with both the base manual transmission and the leather-upholstery upgrade. Sure, the cheapest way to buy a new Vue— which was sold here for the 2002-2007 model years— was to get it with the base transmission: a five-speed manual. You can still buy a new car with a five-on-the-floor manual right now, but only in a handful of cheapmobiles; by the middle 2000s, a tiny-and-ever-shrinking subset of American car shoppers would even consider a three-pedal commuter vehicle. Really, there were only two reasons an American new-car buyer would have considered a non-enthusiast vehicle with a manual transmission in 2004: either an eccentric preference for the good ol' stickshift or just plain penny-pinching. The cheapest possible '04 Vue was the version with four-cylinder 2.2-liter engine, front-wheel-drive, and five-speed manual transmission, and it started at $17,025 (about $26,080 in 2022 dollars). That's what we're looking at here. The optional CVT automatic transmission cost an additional $2,095 ($3,210 today), so it made sense to get the manual if you wanted to save serious money on your Vue. However, this car is loaded to the gunwales with nice equipment upgrades, to the tune of at least the Leather Appointments Package ($755) and the Sports Plus II Package ($1,300) and probably a lot more.  So, a buyer who didn't care about power (so no V6 engine), didn't want all-wheel-drive, liked driving a manual transmission Â… but insisted on power everything and a full-zoot comfy leather interior Â… in a cheap small SUV sold by a fast-fading brand. The conversations with the Saturn salesmen about this thing must have been interesting. Built in Tennessee, sold new in Denver, will be crushed near Pikes Peak.

Saturn Ion steering probe closed by NHTSA

The National Highway Traffic Safety Administration has closed its investigation into faulty electric power steering motors affecting 334,728 Saturn Ions from 2004-2007, because General Motors has issued a recall for them. The group's research found that the part failed at a high rate in the vehicles.
GM recalled over 1.3 million vehicles a few weeks ago, including the Ion, because the power steering could suddenly fail. If broken, the cars could still turn, but it took greater effort. The automaker is also covering 96,324 2003 Ions with a lifetime warranty for their motors, but it's not immediately replacing them.
NHTSA opened its investigation into the motors in September 2011, and it found 4,787 complaints and 30,560 warranty claims that showed failure for the Ion alone. It estimated a complaint rate of 14.3 incidents per 1,000 vehicles and warranty claim rate of 9.1 percent. The investigation also found evidence of 12 crashes caused by loss of steering, two of which resulted in injuries.

GM investing $167m in Spring Hill for new midsize vehicles

General Motors has announced a large investment in its Spring Hill, Tennessee facility. The former home of Saturn production will be getting a $167 million addition to a previously announced $183 million, to cover a pair of new midsize vehicles. The investment is expected to create 1,800 jobs at the factory.
That $350 million is being divvied up for a pair of programs at Spring Hill. The first will take the bulk of the money ($223 million) and create 1,000 of the 1,800 jobs, while the other will take the remaining $127 million and generate the leftover 800 positions. But GM says the investment will cover "midsize vehicle programs." So what could they be?
The leading candidate in our minds is a new crossover for Buick, called the Anthem, that will slot between the Encore and Enclave, but will be slightly smaller than the Equinox and Terrain. As we've explained, the new model will likely be the first product to sport GM's new D2UX platform, which will eventually replace both the Delta and Theta platforms. Spring Hill is already building the Equinox, so there could be some credence to this theory.