2005 Saturn Ion 2 on 2040-cars

Auto blog

Junkyard Gem: 2004 Saturn Vue with manual transmission

GM's Saturn Division has been gone since the final 2010 Auras, Outlooks, Skies, and Vues slunk apologetically out of the showrooms, and I'm doing my best to document the more interesting models from The General's once-revolutionary brand. Some of the later Saturns began life as Opel designs, but the Vue actually was the first vehicle to go on the all-new GM Theta platform; the Opel Antara was thus a Saturn copy, a fact that Saturn fans no doubt trot out when they get shamed by Opel zealots over the Astra. Today's Junkyard Gem is a most unusual Vue, in the sense that its original purchaser was fine with both the base manual transmission and the leather-upholstery upgrade. Sure, the cheapest way to buy a new Vue— which was sold here for the 2002-2007 model years— was to get it with the base transmission: a five-speed manual. You can still buy a new car with a five-on-the-floor manual right now, but only in a handful of cheapmobiles; by the middle 2000s, a tiny-and-ever-shrinking subset of American car shoppers would even consider a three-pedal commuter vehicle. Really, there were only two reasons an American new-car buyer would have considered a non-enthusiast vehicle with a manual transmission in 2004: either an eccentric preference for the good ol' stickshift or just plain penny-pinching. The cheapest possible '04 Vue was the version with four-cylinder 2.2-liter engine, front-wheel-drive, and five-speed manual transmission, and it started at $17,025 (about $26,080 in 2022 dollars). That's what we're looking at here. The optional CVT automatic transmission cost an additional $2,095 ($3,210 today), so it made sense to get the manual if you wanted to save serious money on your Vue. However, this car is loaded to the gunwales with nice equipment upgrades, to the tune of at least the Leather Appointments Package ($755) and the Sports Plus II Package ($1,300) and probably a lot more.  So, a buyer who didn't care about power (so no V6 engine), didn't want all-wheel-drive, liked driving a manual transmission Â… but insisted on power everything and a full-zoot comfy leather interior Â… in a cheap small SUV sold by a fast-fading brand. The conversations with the Saturn salesmen about this thing must have been interesting. Built in Tennessee, sold new in Denver, will be crushed near Pikes Peak.

Saturn Ion steering probe closed by NHTSA

The National Highway Traffic Safety Administration has closed its investigation into faulty electric power steering motors affecting 334,728 Saturn Ions from 2004-2007, because General Motors has issued a recall for them. The group's research found that the part failed at a high rate in the vehicles.
GM recalled over 1.3 million vehicles a few weeks ago, including the Ion, because the power steering could suddenly fail. If broken, the cars could still turn, but it took greater effort. The automaker is also covering 96,324 2003 Ions with a lifetime warranty for their motors, but it's not immediately replacing them.
NHTSA opened its investigation into the motors in September 2011, and it found 4,787 complaints and 30,560 warranty claims that showed failure for the Ion alone. It estimated a complaint rate of 14.3 incidents per 1,000 vehicles and warranty claim rate of 9.1 percent. The investigation also found evidence of 12 crashes caused by loss of steering, two of which resulted in injuries.

GM's got 107 problems and NHTSA's No. 1

General Motors' problems with its recall of roughly 1.6-million vehicles continue to mount. Now that it has emerged that GM knew about the problem since at least 2004 but waited to recall vehicles until February 2014, regulators at the National Highway Traffic Safety Administration have begun a much deeper investigation. NHTSA has sent a 27-page survey to GM that includes 107 questions about the timeline of what led up to the recall, and it has until April 3 to reply. This isn't a simple, multiple-choice test. Automotive News believes that hundreds of pages could be required to answer some of the queries. NHTSA says that it is still investigating GM's response to the recall. "We are a data-driven organization, and we will take whatever action is appropriate based on where our findings lead us," said NHTSA in a statement on its website. If found liable, the automaker could face a fine as high as $35 million and even possible criminal charges, according to Bloomberg. NHTSA's questions include a detailed explanation of GM's examination process; how it will improve the process; why a planned redesign of the cars' key in 2005 wasn't implemented; and specific data on each complaint it received. According to Bloomberg, NHTSA also has records that show the company had a meeting with regulators to discuss the airbag failure in a Chevrolet Cobalt in 2007. New GM CEO Mary Barra has also hired an outside law firm to conduct an independent investigation about what happened. It will include questioning company employees who were involved with the process from the start. The recall stems from faulty ignition switches that shut off the car while driving, and if it occurs the airbags deactivate. Thirteen deaths and 23 crashes have been caused by the problem, according to Bloomberg. If you would like to peruse NHTSA's entire questionnaire for GM, it can be viewed here. News Source: Automotive News – sub. req., National Highway Traffic Safety Administration, BloombergImage Credit: Carlos Osorio / AP / dapd Government/Legal Recalls GM Pontiac Saturn Safety pontiac solstice saturn ion saturn sky pontiac g5