1997 Chrysler Sebring Jx Convertible 2-door 2.4l on 2040-cars

Auto blog

US expands probe into ZF-TRW airbag failure-to-deploy to 12.3 million vehicles

DETROIT — U.S. auto safety regulators have expanded an investigation into malfunctioning airbag controls to include 12.3 million vehicles because the bags may not inflate in a crash. The problem could be responsible for as many as eight deaths. Vehicles made by Toyota, Honda, Kia, Hyundai, Mitsubishi and Fiat Chrysler from the 2010 through 2019 model years are included in the probe, which was revealed Tuesday in documents posted by the National Highway Traffic Safety Administration. It involves airbag control units made by ZF-TRW that were installed in the vehicles. The control units can fail in a crash, possibly because of unwanted electrical signals produced by the crash itself that can disable an air bag control circuit housed in the passenger compartment, according to NHTSA documents. The electrical signals can damage the control circuit, the documents say. ZF, a German auto parts maker which acquired TRW Automotive in 2015, said in a statement that it's committed to safety and is cooperating with NHTSA and automakers in the investigation. The case is another in a long list of problems with auto industry airbags, including faulty and potentially deadly Takata airbag inflators. At least 24 people have been killed worldwide and more than 200 injured by the inflators, which can explode with too much force and hurl dangerous shrapnel into the passenger cabin. The inflators touched off the largest series of automotive recalls in U.S. history involving with as many as 70 million inflators to be recalled by the end of next year. About 100 million inflators are to be recalled worldwide. On April 19, NHTSA upgraded the ZF-TRW probe from a preliminary evaluation to an engineering analysis, which is a step closer toward seeking recalls. So far, only Hyundai and Kia and Fiat Chrysler have issued recalls in the case. Four deaths that may have been caused by the problem were reported in Hyundai-Kia vehicles and three in Fiat Chrysler automobiles. NHTSA opened an investigation in March of 2017 involving the TRW parts in Hyundais and Kias. The upgrade came after investigators found two recent serious crashes involving 2018 and 2019 Toyota Corollas in which the airbags did not inflate. One person was killed. Jason Levine, executive director of the Center for Auto Safety, a nonprofit consumer group, said the ZF-TRW case shows the auto industry thus far has learned very little from Takata.

Chrysler banks $507 million in Q2, trims 2013 earnings forecast

Chrysler has some good news and some bad news. First, profits were up 16 percent over the second quarter of 2012, bringing the Auburn Hills, Michigan-based manufacturer $507 million on the back of strong demand for trucks and SUVs (a recurring theme this quarter, particularly in the US). Q2 revenue was up as well, from $16.8 billion in 2012 to $18 billion in 2013. The bad news is that the Pentastar's overall earnings forecast for net income in 2013 has been trimmed from $2.2 billion to between $1.7 and $2.2 billion, according to Automotive News.
In addition to the adjusted net income forecast, Chrysler tweaked its operating profit from $3.8 billion to between $3.3 and $3.8 billion. This has gone largely unexplained by Chrysler, perhaps hoping the news of a three-percent increase in its transaction prices for Q2 will allow it to sweep this adjustment under the rug.
The star of the show for Chrysler has been its US sales, which saw a 10-percent jump, both bettering the industry average of eight percent and improving over the same stretch of 2012. As with the increase in transaction prices, Chrysler has the new Ram pickup and Jeep Grand Cherokee to thank. Perhaps most worrying from this report, though, is that every brand in the automaker's stable saw an increase in sales... except for the Chrysler brand itself.

Chrysler Recalls Jeep SUVs For Ignition Switches

The ignition switch defects that engulfed General Motors are now a rapidly growing problem at Chrysler. Chrysler said Tuesday it is recalling up to 792,300 older Jeep SUVs worldwide because the ignition switches could fall out of the "run" position, shutting off the engine and disabling air bags as well as power-assisted steering and braking. That's the same problem that has forced GM to recall more than 15 million cars over the last six months. Chrysler's recall covers 2005-2007 Grand Cherokees and 2006-2007 Commanders. The company said it is not sure exactly how many will be recalled, but said it will notify customers by mid-September. Chrysler said an outside force such as a driver's knee can knock switches out of the "run" position. Engineers are working on a fix. The Auburn Hills, Michigan-based automaker, now part of Fiat Chrysler Automobiles NV, said it knows of no related injuries and only one accident. But it said owners should keep clearance between their knees and keys until repairs are made. Chrysler has now recalled more than 1.7 million vehicles for ignition-switch problems. In June, the company added 696,000 minivans and SUVs to a 2011 recall to fix faulty ignition switches. Those recalls covered Dodge Journey SUVs and Chrysler Town & Country, Dodge Caravan and Volkswagen Routan minivans - which Chrysler made for the German automaker - from the 2007 to 2010 model years. Tuesday's recall is the outgrowth of two investigations opened by U.S. safety regulators last month as part of a broader probe into ignition-switch and air-bag problems across the auto industry. The agency wouldn't say Tuesday whether its investigation could lead to recalls at other automakers. The National Highway Traffic Safety Administration said in June that it was investigating Jeep Commanders and Grand Cherokees after getting 32 complaints that a driver's knee can hit the key fob or key chain, causing the ignition switch to move out of position. The federal investigation is still open. The agency said Tuesday that it is requesting additional information from Chrysler to ensure that its repairs will be effective. The investigations and recalls come after GM bungled an ignition-switch recall of older small cars. GM acknowledged that it knew of the ignition problem for more than a decade but failed to recall the cars until earlier this year, when it recalled 2.6 million small cars such as the Chevrolet Cobalt.