2011 Ford E-350 Econoline Van 15 Passenger on 2040-cars

Auto blog

Ford recalling 370,000 Crown Vic, Grand Marquis and Town Car models

The Detroit News is reporting that Ford will recall some 370,000 Crown Victoria (pictured), Mercury Grand Marquis and Lincoln Town Car vehicles from model years 2005 through 2011, for an issue regarding the lower intermediate steering shaft. 355,000 of the vehicles in question were sold in the US, with the other 15,000 sold in Canada.
The report indicates that corrosion of the lower intermediate steering shaft could cause a "loss of steering," presumably because of a partial or complete failure of the part. The report points out the dealers will inspect and replace the offending steering component for recalled cars, and may also secure a lower steering column bearing and replace the upper intermediate steering shaft as needed. The company is unaware of any reports of the faulty part causing any accidents or injuries.
Ford helpfully lists states in which corrosion is more likely to have taken place, mostly in the Snow Belt, as you might guess. Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, Wisconsin, West Virginia, and the District of Columbia are listed.

Ford issues six recalls covering 101,000 vehicles for multiple issues

Ford is announcing six separate recalls for a variety of issues affecting a dozen models and a total of 100,610 vehicles in North America. However, according to Ford spokesperson Kelli Felker, "None of them have caused accidents or injuries." Half of them cover fewer than 1,000 cars.
The largest recall covers 92,022 North American examples (about 83,250 in the US) of some models of the Ford Taurus, Lincoln MKS, Ford Interceptor, Flex and Lincoln MKT from the 2013 and 2014 model years; the 2012-2014 Edge and the 2014 Lincoln MKX. All of them have a potential issue with the halfshaft on the right side that might not be fully seated and could move outward over time. If it shifts too far, the models may no longer be able to drive, and the condition could also allow the vehicles to roll away, even when in Park. Dealers will inspect the shaft to make sure it's seated and will replace the part if necessary.
The next-largest recall covers 5,264 North American examples (4,867 in the US) of the Ford F59 Commercial Stripped Chassis from the 2011-2014 model years. It's possible that an electrical junction box can corrode in areas with salty roads and short circuit. The problem could potentially cause a fire. Dealers will replace the box with an improved design.

Feds looking into Ford Explorer exhaust leak complaints

There may be a burgeoning problem with exhaust leaks in the 2011-2014 model year Ford Explorer. The National Highway Traffic Safety Administration is examining multiple complaints of a gasoline smell in the cabin of these SUVs. However, the exact cause of this problem is still unknown.
"The agency is reviewing all available data and will take appropriate action as warranted," said a NHTSA spokesperson in an email to Automotive News. Owners seem to generally complain on the regulator's website of the smell entering the cabin through the air vents. At this time, the government organization has not yet opened an official investigation into the problem, though. When it does begin inspecting vehicles, NHTSA posts a detailed breakdown of its public data online.
Similar problems have been reported about the Explorer in the past, though. In 2013, Ford issued a recall for the 2013 model year of the SUV due to a fuel leak that could cause drivers to smell a gasoline odor and repaired them again later for another possible leak. In response to Autoblog's questions, Ford responded via email: "We are not aware of a NHTSA investigation. We are currently reviewing the case and in the event that any action is required, we will address it promptly."