2011 Toyota Highlander on 2040-cars

Auto blog

Toyota expands airbag recall to 2.27M vehicles worldwide

Was your Toyota inspected under the company's recall campaign for faulty airbag inflators last year? You might have another trip ahead to have it repaired again. The automotive giant says that it found "the involved serial numbers provided by the supplier were incomplete, and did not include all of the potentially involved inflators," according to its official announcement. That means more replacements are needed.
Toyota's April 2013 inflator recall covered the Corolla, Matrix and Tundra from the 2003 and 2004 model years, the Sequoia from 2002 to 2004 and the Lexus SC 430 from 2002 to 2004. At the time, the company said it would need to inspect about 510,000 vehicles in the US but only expected to replace around 170,000 inflators.
However, the latest announcement increases that figure to about 766,300 vehicles in the US. Toyota spokesperson Cindy Knight told Autoblog that the new amount is the combination of owners who need to have their vehicle looked at again and those who didn't come in for the initial recall. The company learned about the problem when Takata, the supplier, provided it with an improved list of the faulty part's serial numbers. According to The Detroit News, the latest recall affects about 2.27 million vehicles from them worldwide. Knight said owners would receive notification of the problem around the end of the month but repairs would come in phases because the automaker doesn't have all of the necessary parts at the moment.

177k Toyota Camry Hybrids being recalled for brake issue

It looks like Consumer Reports might be getting part of what it wants regarding the Toyota Camry Hybrid and its braking system. Toyota is issuing what it calls a limited service campaign, rather than a full recall, covering about 177,500 of the hybrid sedans from the 2007 through 2011 model years because of an issue with the cars' brake fluid reservoirs.
The models have a filter separating two chambers of the brake fluid reservoir, and the part can get clogged over time. If this happens, the fluid level in one of the chambers can get too low and eventually cause the power assist to fail. There are multiple warning lights on the dashboard that illuminate over time if the filter gets obstructed, though. The company is replacing the entire reservoir with an improved unit, and the fix takes about two hours to perform.
Consumer Reports recently began asking for a recall on these models for the potentially clogged filters. The magazine also reported a second issue with the ABS brake actuator that could lead to a difficult to depress brake, but Toyota has increased the warranty on the part to 10 years or 150,000 miles.

Mazda previews straight-six, affirms upcoming crossover with Toyota hybrid system

Buried in Mazda's generally bleak second-quarter earnings report were a few juicy nuggets of news. Though the company had an operating loss of $502 million and sales are down 21 percent in part due to the COVID-19 pandemic, the Hiroshima-based firm has big plans for the future. Enthusiasts and environmentalists alike should take note. Firstly, Mazda showed an image of its upcoming straight-six engine. Essentially, it's the SkyActiv four that powers all of Mazda's current lineup, but with two additional cylinders. Unsurprisingly, the company says that it can be engineered to fit any of the current SkyActiv guises — the standard octane-variable gasoline powered G, the diesel D, and the sparkless-ignition X. The big six will pair with a new eight-speed automatic and can be combined with either a plug-in or 48-volt mild hybrid system, promising big power and efficiency. Reassuringly, Mazda says it's committed to offering this six in a rear-wheel-drive platform, which will underpin the 6 sedan's successor, as well as a midsize SUV. Both the platform and powertrain are said to be compatible with all-wheel-drive layouts as well. Which brings us to the second bit of news. Mazda also pictured a four-cylinder engine with hybrid technology. The financial report confirmed that Mazda will employ  Toyota's wildly successful hybrid system in an upcoming SUV. It's not that Mazda is taking advantage of Toyota's free access to all its hybrid patents until 2030. Mazda and Toyota have a capital tie-up and are nearing completion on a $2.3 billion joint-venture factory in Alabama with a 300,000-vehicle annual capacity. According to the Huntsville Business Journal, the firms have hired 750 employees so far, with room for 3,250 more. In return, Mazda will launch a European compact based on Toyota's Yaris Hybrid. The move is necessary for Mazda, which has lagged behind in electrification and in meeting the fleet emissions requirements in the European market. In return, by 2022, Mazda may even share the inline-six engine with Toyota and Lexus. While the hybrid crossover and compliance with EU rules will no doubt help the environment, we not-so-secretly hope that these strategies will keep Mazda profitable enough to bring that straight-six, rear-drive sports sedan to market.