1997 Saturn Sl1 166,103 Miles Have Key Half Motor Missing on 2040-cars

Auto blog

US database may have overstated deaths in GM ignition switch recall

The FARS analysis didn't take into account fatal accidents where the airbags weren't supposed to deploy. Earlier today, we reported that the actual death toll attributable to GM's ignition switch problem had crested the 300 mark according to new research, well up from the original reports of 12 to 13 deaths. Now, word is breaking that the US government database that informed the study that the report was based on may have significantly overstated the correlation between the study and the GM recall. The initial study was conducted by Friedman Research on behalf of the Center for Auto Safety, and used something called the US Fatality Analysis Reporting System. To recap, the study claimed that over a 10-year period, 303 people were killed in Chevrolet Cobalt and Saturn Ion coupes and sedans when their airbags failed to deploy. These undeployed airbags were then linked to GM's ignition switch recall, which as we've explained before, can turn the ignition out of the "run" position and into the "off" or "accessory" position, disabling the airbags in the process. Now, according to a report from The Detroit News, which cites research from the Insurance Institute for Highway Safety and the National Study Center for Trauma and EMS at the University of Maryland, the FARS analysis didn't take into account fatal accidents in conditions where the airbags weren't supposed to deploy (which isn't to say crashes and deaths weren't caused by loss of control from the ignition switching off in the GM vehicles). According to the report, this was a significant number of the cases. There is another potential problem, too. According to that same report, the National Highway Traffic Safety Administration uses both FARS and another database on fatalities, called the National Automotive Sampling System/Crashworthiness Data System (NASS/CDS). Where FARS uses what the DetNews calls "not always reliable" police data to record vehicular deaths within 30 days of a crash, NASS/CDS relies on what's known as a probability sample. It collects data on 5,000 crashes each year – including some found in the FARS database – to calculate a probability figure. According to a 2009 IIHS study, "Among crashes common to both databases, NASS/CDS reported deployments for 45 percent of front occupant deaths for which FARS had coded nondeployments." In plain English, FARS doesn't provide a reliable count airbag deployments.

NHTSA opens safety investigations into Toyota, GM and Honda crossovers

The National Highway Traffic Safety Administration is evidently keeping itself very busy these days, as the federal agency has just announced it is launching or renewing investigations into Toyota, Honda and General Motors crossovers.
2006-2008 model year Toyota RAV4 crossovers are under review for allegations of rear tie-rod rust which can result in failure. NHTSA also said it is probing some 35 complaints about 2005 Honda Pilot models with inappropriate activation of the vehicles' stability control system. The alleged malfunction can cause the vehicles to slow down or stop in bad unsafe situations. At the moment, NHTSA is reviewing a petition regarding the Pilot issue, a move that will determine whether it needs to open a full-blown investigation.
In addition, Saturn Outlook and GMC Acadia three-row crossovers built in 2007-2009 are getting looked at for "loss of low beam headlamp" function. One complainant said the wiring in his Outlook overheated and melted. NHTSA says it has received 415 complaints about the problem and a GM spokesman confirmed that the automaker already started a "Customer Satisfaction Program" in December to address the issue.

GM investing $167m in Spring Hill for new midsize vehicles

General Motors has announced a large investment in its Spring Hill, Tennessee facility. The former home of Saturn production will be getting a $167 million addition to a previously announced $183 million, to cover a pair of new midsize vehicles. The investment is expected to create 1,800 jobs at the factory.
That $350 million is being divvied up for a pair of programs at Spring Hill. The first will take the bulk of the money ($223 million) and create 1,000 of the 1,800 jobs, while the other will take the remaining $127 million and generate the leftover 800 positions. But GM says the investment will cover "midsize vehicle programs." So what could they be?
The leading candidate in our minds is a new crossover for Buick, called the Anthem, that will slot between the Encore and Enclave, but will be slightly smaller than the Equinox and Terrain. As we've explained, the new model will likely be the first product to sport GM's new D2UX platform, which will eventually replace both the Delta and Theta platforms. Spring Hill is already building the Equinox, so there could be some credence to this theory.