1977 Mercury Cougar Xr-7 "barn Fresh" 25,825 Miles on 2040-cars

Auto blog

NHTSA investigating 500k Ford and Mercury cars for lighting failures

The Ford Crown Victoria and Mercury Grand Marquis might be long gone as new models in showrooms, but the National Highway Traffic Safety Administration might check them out yet again for a potential problem. At the urging of North Carolina Consumers Council, the agency may open another investigation into the front lighting control module on vehicles from the 2003-2005 model years, and NHTSA estimates the issue could affect 517,945 vehicles. If the module stops working, it can cause a complete failure of all forward lighting, including the headlights. NHTSA previously investigated the issue in 2008 and 2009 but found no need for a recall, according to Bloomberg. Ford also extended the warranty on the part to 15 years or 250,000 miles. To prompt this new request, the North Carolina Consumers Council received a letter from a woman experiencing the module's failure. Upon further investigation, the council found 604 complaints of this problem on NHTSA's website, including seven crashes. Furthermore, the group has alleged that dealers told customers that the parts to perform the replacement weren't available, despite the extended warranty. According to the government agency, "A defect petition has been opened to evaluate the issue and make a grant or deny decision." Ford spokesperson Kelli Felker tells Autoblog via email, "We will cooperate with NHTSA, as we always do." You can read the council's complete letter to the Feds in PDF format, here. INVESTIGATION Subject : Loss of headlamp/exterior lighting Date Investigation Opened: APR 01, 2015 Date Investigation Closed: Open NHTSA Action Number: DP15002 Component(s): EXTERIOR LIGHTING All Products Associated with this Investigation Vehicle Make Model Model Year(s) FORD CROWN VICTORIA 2003-2005 MERCURY GRAND MARQUIS 2003-2005 Details Manufacturer: Ford Motor Company SUMMARY: The Office of Defects Investigation (ODI) has received a petition from the North Carolina Consumers Council, Inc. requesting a defect investigation of an alleged defect condition resulting in headlight and/or exterior lighting failure on 2003-2005 Ford Crown Victoria and Mercury Grand Marquis vehicles. The petition letter is attached for review. The petitioner alleges a defect in the lighting control module that powers the headlights which can result in the loss of vehicle headlights and/or all exterior lighting while driving. ODI has previously investigated this issue under PE08-066 which was closed without a defect finding.

Ford recalling 126,000 Fusions and Milans over wheel separation concern

Ford has announced a recall of certain Ford Fusion and Mercury Milan vehicles after an investigation by the National Highway Traffic Safety Administration. A total of 128,616 2010 and 2011 models equipped with steel wheels may have been manufactured with wheel studs that could crack and split over time. If that happens, the vehicle may experience a wheel separation.
According to The Detroit News, the company is aware of a total of 30 wheel separation incidents, one of which occurred on the front of the vehicle. Even so, no injuries have been reported as a result of the defect.
The problem apparently stems from the fact that the mounting pads on the vehicles' steel wheels may have been faulty from the factory. In addition, the wheel mounting face on rear disc brakes may not have been installed properly. Ford will inspect the rear disc face and replace them as necessary. In addition, the company will replace all of the vehicle's wheel studs free of charge. Head to the NHTSA website for more information, and click past the jump to view the full recall notice.

Junkyard Gem: 1981 Mercury Cougar XR-7

The story of the Mercury Cougar involves more plot twists and unexpected digressions than that of just about any other Detroit car, with successive Cougar generations based on the Ford Mustang (1967-1973), the Ford Torino and/or Thunderbird (1974-1979), various Fox Fords including the Thunderbird (1980-1988), the MN12 Thunderbird/Lincoln Mark VIII (1989-1997), and the Ford Mondeo (1999-2002). There were wagon and sedan Cougars for brief periods, just to confuse everybody, and the rakish XR-7 Cougars sometimes lived on different platforms from their ordinary non-XR-7 counterparts. I think the Late Malaise Era Fox XR-7s are among the most interesting of the bunch, so I was quite excited to spot this tan-over-gold '81 in a Denver yard. I tried to count the number of screaming-cat badges on and in this car and gave up once I hit a dozen. The steering wheel, door panels, C pillars, center console, and — of course — the hood ornament all boast snarling felines. Earlier Cougars had emblems showing full side views of stalking catamounts, but the Cougar logo for the 1980s showed just the head. This car got the optional center console, which I hear is quite a rarity. You had to pay $174 extra (that's around $513 in 2020 dollars) for an AM/FM/cassette audio system in the '81 Cougar, but at least the air conditioning was standard equipment. Believe it or not, thieves used to steal these radios. Kumpf Lincoln-Mercury still exists in Englewood (as Landmark Lincoln), and the yard that now houses this car can be found just 15 miles up Broadway on the north side of Denver.  The padded landau roof hasn't fared so well beneath the fierce Colorado sun, but overall this car seems very solid. Sadly, only the Mustangs and (once in a long while) Fairmonts get much love from the Fox Ford crowd these days. Three Mercury "wire wheel" hubcaps and one from a Lincoln. The base engine in the 1981 XR-7 was the "Thriftmaster" 200-cubic-inch (3.3-liter) straight-six, but very few XR-7 buyers would have refrained from checking the box for one of the two optional Windsor V8s. I can't tell if we're looking at the 255-cubic-inch (4.2-liter) version or the 302-cubic-inch (5.0-liter) one here, but real-world drivers might not have noticed the difference between the 120-horse 255 and the 130-horse 302, anyway. The non-XR-7 Fox Cougars had five-speed manual transmissions as base equipment (which nobody wanted), but all 1981 XR-7s had automatics.