2001 Ford Ranger Xlt Extended Cab Pickup 4-door 4.0l With Plow & Cap on 2040-cars

Auto blog

Malcolm Gladwell reflects on engineering, recalls, and compromise

Journalist Malcolm Gladwell has made a career taking on big, complicated topics and humanizing them to make the unwieldy understandable. He has already done this in bestsellers like The Tipping Point and Outliers, and now he has brought the same approach to automotive recalls in a long piece for The New Yorker. The article titled The Engineer's Lament is framed around an interview with the former head of Ford's recall office about the famous Ford Pinto campaign where the position of the compact's fuel tank could cause it to explode in rear-end collisions. Plus, there are detours into Toyota's unintended acceleration cases and the General Motors ignition switch problem. While all the history is illuminating, the heart of the story comes from an examination at the thought process of engineers, and how their thinking differs from other professions. Gladwell comes off as sympathetic to auto engineers in this piece. While he admits that they often approach problems in a sterile way, the writer doesn't try point that out as a failing. It's merely a fact to be understood. The story itself is quite lengthy, but well worth a read if you have the time for an insiders view into how these recalls are assessed on the inside.

NHTSA investigating Ford Fiesta for faulty door latches

The National Highway Traffic Safety Administration has opened a preliminary investigation on the 2011-2013 Ford Fiesta because the regulator has received 61 complaints from drivers, including one claim of an injury, about the doors on the subcompacts failing to latch and sometimes even flying open while driving. NHTSA has estimated that the problem could affect as many as 205,000 vehicles.
NHTSA is still gathering further data about the problem, but looking at the complaints so far, both front and rear doors appear to be potentially involved with the alleged failures. Among the reports, there are 12 claiming that the door opened while driving. Several also indicate the "Door Ajar" warning illuminating during this problem. The one purported injury happened when someone attempted to shut the door, and it bounced back.
Ford spokesperson Kelli Felker told Autoblog via email, "We are cooperating with NHTSA on this investigation, as we always do." Scroll down to read the report from NHTSA.

VW going turbo-only in 3 to 4 years

This really was a matter of when, rather than if. Volkswagen will apparently be the first manufacturer to phase out naturally aspirated engines in favor of turbocharging its full slate. VW is kind of responsible for ushering in this push towards small-displacement, turbocharged engines that's taken the industry by storm. When it dropped its direct-injection, 2.0-liter turbo in the 2005 GTI it demonstrated that strapping an iron long to an engine can enhance the powertrain as a whole. VW made fuel economy gains, while also giving a linear, non-laggy turbo experience that it has replicated, model-after-model, to this day.
Speaking with The Detroit News, Volkswagen's executive Vice President of Group Quality, Marc Trahan, told the paper that, "We only have one normally aspirated gas engine, and when we go to the next generation vehicle that it's in, it will be replaced. So three, four years maximum."
Really, it's hard to get teary-eyed about either of these engines going away. VW has access to smaller powerplants that could easily match the performance of the 2.5 five-cylinder and the 3.6 V6, while gobbling up less fuel and providing a better driving experience. What we are sad about is that a similar statement about the extinction of NA engines came from the Vice President of Powertrain Engineering at Ford, Joe Bakaj. We'd certainly get teary-eyed over a world without Ford's excellent 5.0-liter V8.