2014 Ford Flex Se on 2040-cars

Auto blog

Ford recalls more than 550,000 trucks and SUVs for various safety issues

Ford announced safety recalls for its current F-150 pickup along with several Ford and Lincoln crossovers early Wednesday. The recalls cover more than 550,000 vehicles and address various safety defects, ranging from a fire hazard to potential loss of braking power.  The most far-reaching of the recalls covers approximately 550,000 examples of the 2015-2018 Ford Edge and 2016-2018 Lincoln MKX, which may have been assembled with defective front brake jounce hoses (also commonly referred to as "flex lines"). These hoses run from fixed points on the chassis to the individual front brake calipers. Defective hoses could potentially rupture, allowing brake fluid to leak and resulting in a loss of braking function. Ford will replace the components in question with revised parts.  The next-largest recall is for roughly 3,000 2020 Lincoln Corsair crossovers. The affected models may have been assembled without proper clearance between their rear suspension springs and toe link brackets. The components could potentially make contact, wearing down the protective coating on the rear coil springs, allowing corrosion to occur over time. This corrosion could eventually lead to a failure of the spring. If this happens while the vehicle is being driven, it could result in a sudden change to the vehicle's handling characteristics, and the spring fragments could potentially cause further damage to the car or surrounding traffic.  Ford says owners will be notified that their Corsairs need to be inspected; if there is not adequate clearance between the rear suspension components, Ford's service technicians will remove material from the toe link bracket to allow for operation without contact.  The final (and by far the smallest) recall is for the 2020 F-150. Some units may have left the factory with the incorrect retention nut on the hot lead to the starter motor. Ford says it can cause increased heat generation or electrical arcing, which could potentially result in a fire. Ford says this issue is limited to just a few hundred examples sold in the United States. Dealers will inspect the vehicles and replace the nut if necessary.       

1947 Chevy rat rod pickup leaves rubber and smoke in its wake

Cool comes in multiple flavors. One one hand, we have the sophisticated attraction of svelte design and the efficient use of power. Of course, on the other hand there is the allure of being the bad boy and going against the grain. That is part of the appeal of rat rods. Ideally, they are built without rules to an owner's specific tastes, and this widened and heavily modified 1947 Chevrolet pickup rod is a perfect example of that spirit.
Coming down the highway with a bent grille, rusted body and pouring smoke, it looks like the pickup from hell. It backs up the looks with some very impressive mechanicals too. Owner Troy Gubser says that the truck packs a Ford Power Stroke diesel with to 42 pounds of boost that runs out of 8-inch exhaust stacks at the back. He claims it managed 505 horsepower and 885 pound-feet of torque on the dyno. To harness all that power, this hot rod has a ZF five-speed manual gearbox with a ceramic clutch and short-throw shifter. Plus, it has cool little features like a doorbell on the tailgate that operates an air horn.
You might not expect a truck like this to actually be useful, but it has a fifth wheel coupling to haul an RV around drag races and car shows. The air suspension also probably keeps the ride fairly comfy when Gubser wants it to be. Scroll down to check out this beastly rat rod pickup and watch it engage in some diesel drag racing. Warning, there is some NSFW language.

Ford idling Michigan Assembly Plant to trim Focus, C-Max supply

Ford will be putting the brakes on production at its Michigan Assembly Plant in Wayne, MI, idling production during the weeks of October 28 and December 16. Ford is citing the first drop in US sales in 27 months, a 4.2-percent dip in September, as the impetus for trimming their supplies, according to Automotive News.
Ford's deft management of its supplies has been part of its success over the years, and seeing supplies of Focus and C-Max, the two vehicles built at MAP, rise from 58 and 108 days, respectively, to 71 and 122 days over the span of a month was apparently all that was need to justify the trimming. As AN points out, the rule of thumb for many automakers is to maintain a 60-day supply of vehicles.
"Ford has been focused on keeping their pricing in check. Their operating margin is in double digits. Nobody else is there and they're obviously very proud of that," Alan Baum, an auto analyst with Baum & Associates told AN. Keeping the supply chain operating smoothly and not increasing supplies too much is crucial to that healthy profit margin. After all, a large supply lowers prices ,which, in turn, cuts profit. So while this news might not be great for employees at MAP, who now have an extra two weeks of vacation time, it's far from a sign of problems in Dearborn. Quite the opposite, actually.