2010 Ford F-250 Xl 4dr 4wd 4x4 Pickup Truck on 2040-cars

Auto blog

Rolling footage of the 2015 Ford Mustang hits YouTube [w/video]

Just in time for the holidays: Ford took the 2015 Mustang to Route 66 to cook up rolling footage, and we've been given some of the leftovers ahead of the meal. There are no burnouts, no donuts, no revving, and thankfully, no music. It's just two minutes and 26 seconds of the new pony car running free in the desert.
So in case you needed more visualizing help, the video below will help you start imagining how you'll look in your 2014 Christmas present to yourself...

Ford recalls 90,736 vehicles due to engine valve issue

Ford will recall 90,736 vehicles as engine intake valves in the vehicles may break while driving, the National Highway Traffic Safety Administration (NHTSA) said on Saturday. The recall impacts certain 2021-2022 Bronco, F-150, Edge, Explorer, Lincoln Nautilus, and Lincoln Aviator vehicles equipped with either a 2.7L or 3.0L Nano EcoBoost engine, the NHTSA said. According to documents posted by NHTSA and sourced from the automaker, "The engine intake valves may break while driving, which can result in engine failure and a loss of drive power." Following an investigation that started in January, 2022, Ford found 22 instances where "the engine intake valves fractured and fell into the combustion chamber of the engine causing catastrophic engine damage." The automaker's analysis continues: "Ford identified that the potential root cause of the failures was engine intake valve failure due to valves that exceeded the designed specification for hardness, were brittle, and more likely to fracture. Ford determined that this was due to the supplier’s grinding processes and the sensitivity of the intake valve material to grinding processes that were not within control specifications. The intake valve material was changed for vehicles produced after October 31, 2021." Fixing the problem will require replacement of the entire engine. "Dealers will inspect each vehicle to determine its cumulative number of engine cycles. For vehicles that do not meet the engine cycle threshold, dealers will accumulate high revolutions per minute (rpm) engine cycles per a service procedure. Engines will be replaced on vehicles that do not pass the engine cycle accumulation," Ford says.

Ford recalls nearly 200,000 Expeditions and Navigators for fire risk

Ford is recalling 2015-2017 Expeditions and 2015-2017 Lincoln Navigators because the front blower motor could fail and cause a fire. In total, 198,482 Expeditions and Navigators will be recalled. In the official recall documents posted by NHTSA, Ford says that it “has not identified the cause of this condition.” However, Ford also says it is currently aware of 25 fire allegations related to the blower motors on these vehicles. Despite not strictly identifying the cause of blower motor fires, Ford put forth a theory in its fieldwork analysis of the issue.  “In June 2022, based on component analysis, Ford Engineering theorized that a mispositioned blower motor brush holder spring could cause an internal short or localized heating of the brush spring or holder. It is believed that when a fire initiates on the blower motor, it does so at the positive brush holder location. The variable blower controller would remain operational and there would be no signs of an overheated relay. Field data indicates that this concern typically occurs at a higher time in service, and on vehicles with higher mileage.” Since the blower motor is located on the passenger side interior behind the glovebox, the fires that start are interior fires. Ford isnÂ’t aware of any accidents related to this issue, but there is one claim of burnt hands and fingers as a result of a fire. According to Ford, warning signs of an impending fire or failed blower motor include an inoperative fan, burning smell and/or smoke from the instrument panel vents while the vehicle is on. To remedy this situation, Ford is recalling the affected SUVs and replacing the blower motor assembly with a revised part. The new part uses a blower motor assembly design utilized on other applications. If folks with these SUVs experience any symptoms of blower motor failure before the new part becomes available, Ford says they can take their vehicle to the dealer to have it replaced with a part of the same design. Once the redesigned part becomes available, the dealer will then swap it in. Owner notification letters are expected to begin on September 12 this year. Related video: This content is hosted by a third party. To view it, please update your privacy preferences. Manage Settings.