2004 Ford Expedition Xlt Sport Utility 4-door 4.6l on 2040-cars

Auto blog

Ford recalls 90,736 vehicles due to engine valve issue

Ford will recall 90,736 vehicles as engine intake valves in the vehicles may break while driving, the National Highway Traffic Safety Administration (NHTSA) said on Saturday. The recall impacts certain 2021-2022 Bronco, F-150, Edge, Explorer, Lincoln Nautilus, and Lincoln Aviator vehicles equipped with either a 2.7L or 3.0L Nano EcoBoost engine, the NHTSA said. According to documents posted by NHTSA and sourced from the automaker, "The engine intake valves may break while driving, which can result in engine failure and a loss of drive power." Following an investigation that started in January, 2022, Ford found 22 instances where "the engine intake valves fractured and fell into the combustion chamber of the engine causing catastrophic engine damage." The automaker's analysis continues: "Ford identified that the potential root cause of the failures was engine intake valve failure due to valves that exceeded the designed specification for hardness, were brittle, and more likely to fracture. Ford determined that this was due to the supplier’s grinding processes and the sensitivity of the intake valve material to grinding processes that were not within control specifications. The intake valve material was changed for vehicles produced after October 31, 2021." Fixing the problem will require replacement of the entire engine. "Dealers will inspect each vehicle to determine its cumulative number of engine cycles. For vehicles that do not meet the engine cycle threshold, dealers will accumulate high revolutions per minute (rpm) engine cycles per a service procedure. Engines will be replaced on vehicles that do not pass the engine cycle accumulation," Ford says.

2016 Ford Mustang SVT hides big power under its domed hood

With a number of 2015 Ford Mustang versions finally available to configure, the fun of speculating about next year's high-performance 'Stang can now begin. It looks like Ford has something seriously fun planned too. One of our spy photographers just snapped some fresh pics of the 2016 Mustang SVT, which is believed to be hiding the final body shape under all of that heavy camouflage.
Ford clearly doesn't want prying eyes looking at its new pride and joy. It would be hard to put much more obfuscation on a car than this one wears - it even has mesh baffles around the exhausts to conceal how many there are and panels over the wheels to hide their design. However, the Blue Oval can't keep everything a secret. The biggest clue that something special is hidden underneath is the massive hood bulge and vent in front of it. Clearly, whatever is under there is hungry for cool air. The shape of the camo indicates that there may be fender vents on each side, and there are also obscured outlets behind the front wheels likely to pull cool air through the brakes. At the rear, the concealment does its job, making it hard to observe any big changes. The fact that Ford wants it kept such a secret might indicate something, though.
A few photos of the interior show far less cover than the outside. You can easily make out the model's 6,500 rpm redline with a possible 7,000 rpm over-rev function. The big Recaro sport seats also look quite supportive.

How Ford hid the 2015 Mustang from spy photographers

Now that we've finally seen the 2015 Ford Mustang, it's fun to go back and look at the spy shots we spent months pouring over, trying to dissect what was under all the camouflage. For the most part, Ford did a good job of concealing the car from spy photographers, and it released a video showing how much work went into doing so.
As crude as the Mustang's camo looked, all of the hard plastic, foam, vinyl and ratchet straps were actually created and put in place by a specific design team. The whole idea was to hide the car's identity, but it certainly ended up acting as a magnet for attention, too. According to Ford's press release, it took less than an hour for spy shots to appear online after the car was taken on public roads for the very first time - this is likely in reference to our first official spy shots of the Mustang from June, shown in the gallery below.
Scroll down for a press release and video, which shows footage of the 2015 Ford Mustang testing with minimal camouflage. This is probably the same track session where we got our first look at the Mustang's face back in August.