Extended-short-sport-rubber Floors-cloth-4.0l Gas-4wd on 2040-cars

Auto blog

10 automakers shack up in Detroit hotel to talk Takata airbags

Since Takata has decided not to take the lead concerning potential issues with its airbag inflators, the automakers have. Perhaps that's unsurprising, since it's the automakers, not Takata, that will take a beating on the dealership floor if consumers decide its models are a health hazards. The Detroit News reports that Toyota, Honda, General Motors, Ford, Chrysler, Mazda, BMW, Nissan, Mitsubishi and Subaru met in a hotel conference room near the Detroit Metropolitan Airport last week to sort out a way to understand the technical issues involved. So far, faulty airbag inflators have been ruled the cause of five deaths and 50 injuries around the world, but neither Takata nor investigators understands exactly why the inflators are malfunctioning. The National Highway Traffic Safety Administration recently asked Takata to issue a national recall, Takata declined, citing a minuscule failure rate and the fact that it's still investigating the issue. Toyota and Honda then made an industry-wide appeal for "a coordinated, comprehensive testing program" that would pinpoint the problem inflators and get them replaced, and that's what the Detroit meeting was about. Numerous issues, however, will make this a long row to hoe: simply getting the parts to replace the nearly 20 million inflators in cars recalled around the world so far - even working with other suppliers - will take a years, but more importantly, no one knows if the replacement inflators currently being installed will suffer the same issue. Answers will hopefully come quickly with Takata, the ten automakers and NHTSA all independently investigating the problem.

Ford recalls more than 550,000 trucks and SUVs for various safety issues

Ford announced safety recalls for its current F-150 pickup along with several Ford and Lincoln crossovers early Wednesday. The recalls cover more than 550,000 vehicles and address various safety defects, ranging from a fire hazard to potential loss of braking power.  The most far-reaching of the recalls covers approximately 550,000 examples of the 2015-2018 Ford Edge and 2016-2018 Lincoln MKX, which may have been assembled with defective front brake jounce hoses (also commonly referred to as "flex lines"). These hoses run from fixed points on the chassis to the individual front brake calipers. Defective hoses could potentially rupture, allowing brake fluid to leak and resulting in a loss of braking function. Ford will replace the components in question with revised parts.  The next-largest recall is for roughly 3,000 2020 Lincoln Corsair crossovers. The affected models may have been assembled without proper clearance between their rear suspension springs and toe link brackets. The components could potentially make contact, wearing down the protective coating on the rear coil springs, allowing corrosion to occur over time. This corrosion could eventually lead to a failure of the spring. If this happens while the vehicle is being driven, it could result in a sudden change to the vehicle's handling characteristics, and the spring fragments could potentially cause further damage to the car or surrounding traffic.  Ford says owners will be notified that their Corsairs need to be inspected; if there is not adequate clearance between the rear suspension components, Ford's service technicians will remove material from the toe link bracket to allow for operation without contact.  The final (and by far the smallest) recall is for the 2020 F-150. Some units may have left the factory with the incorrect retention nut on the hot lead to the starter motor. Ford says it can cause increased heat generation or electrical arcing, which could potentially result in a fire. Ford says this issue is limited to just a few hundred examples sold in the United States. Dealers will inspect the vehicles and replace the nut if necessary.       

Lincoln Nautilus, Ford Edge latest prediction: Production ends in July 2024

In June, Auto Forecast Solutions put out a report compiled by its vice president of global forecasting, Sam Fiorani. One item in the report covered how Fiorani had heard from "multiple sources" that Ford shut down the program to replace the Edge crossover in 2023. Assuming this came to pass, with the Lincoln Nautilus based on the Edge, the inference is that the Nautilus would retire at or around the same time. Ford's response to media queries about the report was either "No comment" or PR-speak deflection. Lincoln's statement on the matter to Motor1, a crafty non-answer, was, "The Nautilus plays and will continue to play an important role in Lincoln’s growing SUV portfolio which includes the Corsair, Aviator and Navigator. Lincoln is investing in growth segments like SUVs and we have no plans to exit the segment." It's possible Lincoln has no plans to leave the segment, but the Nautilus might, according to a fresh, unsourced report in Ford Authority. The site claims the Nautilus will end production at the Oakville Assembly Plant in Ontario, Canada, in July 2024.  Again, we can't know how much, if any of this, is true. But we're zeroing in on a timeline for the potential end of the Edge and Nautilus in the U.S. Those are the only two products Oakville currently builds, and when the Canadian union Unifor asked Ford about the reports in June, Ford couldn't offer union reps anything concrete or reassuring. The Detroit News quoted Unifor chief Jerry Dias as saying of the automaker, "There is no question, they are going through a major evaluation of their portfolio, based on a whole host of things."   We could be seeing one of the earlier theories for Edge's potential demise coming true. Some analysts suspect Ford could be pruning its crossover lineup because it has too many similarly-sized offerings at the moment, the Edge hasn't met its sales targets in Europe, and more compact crossovers are on the way that could bring better street cred if they're associated with the Bronco or Bronco Sport. Unifor and Ford are now in negotiations over a new contract, so it's possible we'll get more clarity in the next month or so about Ford's plans and what will come of Oakville and its roughly 4,000 workers. If Ford walks away from the assembly plant, it will only have two engine plants left in Canada, and no vehicle assembly north of the border for the first time in about a century.