2003 Ford F-150 Xlt Starts Runs Rough on 2040-cars

Auto blog

Ford recalls 382k vehicles across six campaigns

Ford needs to repair a total of 381,633 vehicles in North America across six newly announced campaigns, including five safety recalls and one compliance recall. By far the largest of these campaigns covers the 342,271 examples of the 1998-2003 Windstar to double check an earlier recall repair. Among these, 283,413 are in the US and 58,858 are in Canada. The combination of corrosion and stress can cause cracks in the rear axle and eventually lead to the part to snap completely. The company reports a small number of accidents might be connected to this, but there are no injuries. The minivans were recalled for this issue back in 2010, and it was investigated by NHTSA. According to Ford's latest announcement, the reinforcement brackets on some of these models might not have been installed correctly. This time, dealers will perform an inspection. Minivans with incorrectly installed brackets will get a new rear axle. The rest of the owners will be offered a deal to replace the part at a reduced cost. The next largest campaign covers 36,857 examples of the 2015 F-150 to fix a problem with the adaptive cruise control. Specifically, there are 33,481 affected trucks in the US, and 3,376 in Canada. According to Ford, "when passing a large, highly reflective truck" the radar in the system can misidentify a semi as being in the same lane as the pickup. The collision warning system would then activate, slowing the F-150. There's one report of an accident with this happening but no injuries. The fix is simply an update to the adaptive cruise control module software. Ford also has a recall for 1,477 examples of its 2016 F-53 and F-59 stripped chassis models, and they're all located in the US. A manufacturing issue might allow the trucks to shift into reverse without the driver first applying the brakes. There are no reports of any accidents from this, though. To repair the problem, the models get a new transmission shift control bracket and an adjustment to the shift cable. The Blue Oval's safety compliance recall covers 708 examples of the 2016 Fusion and Lincoln MKZ, including 658 of them in the US, 28 in Canada, and 22 in Mexico. On these models, a manufacturing problem with the fuel tank could allow it to crack in a crash, which isn't allowed under federal rules. There are no reports of accidents, injuries or fires. The fix will be a new fuel tank for all of them. The company is also repairing 251 units of the 2015 Taurus and Lincoln MKS, plus the 2016 Explorer.

Ford recalls 462,000 SUVs over faulty rear camera

Ford has had some issues with its backup cameras in recent years, and the troubles are continuing with yet another recall announced today. In this recall, certain Ford and Lincoln vehicles equipped with the 360-degree parking camera could lose the rear-view camera feed. The newest recall affects some 462,000 vehicles worldwide, Reuters reports, including 382,759 in the U.S. under NHTSA recall 23V-022. The recall applies to the 2020-2023 Ford Explorer and Lincoln Aviator, as well as the 2020-2022 Lincoln Corsair. The remedy involves dealers updating the vehicles’ image processing module software free of charge. This latest issue expands a previous recall, and applies to vehicles that have already been serviced under recall 21V-735. Owners will be notified by mail around February 20, and owners can also contact Ford customer service at 1-866-436-7332. Ford told NHTSA that it first became aware in October 2021 of a small number of complaints of a blue screen from the rear camera feed on vehicles that had already been repaired. Ford worked with suppliers to track down the potential issue, and said warranty claims remained low until December 2022, when it started to see more claims for blue screens in vehicles produced after the last remedy, at which point Ford ordered a stop-ship on those vehicle lines. Ford said itÂ’s aware of 17 minor accident reports related to the issue, but no injuries. In addition to this recall, Ford has had other camera issues in the past few years that resulted in recalls. NHTSA recall 22V-151 applied to 2021-2022 Edge SUVs experiencing “a distorted, black and white, or discolored screen” when reversing. 2021-2022 Ford Broncos had an issue where the rear-view camera would remain on even after the vehicle was put back into a forward gear. Last year, Ford recalled 330,000 Mustangs for faulty cameras, as well as 277,000 Super Duty trucks over foggy rear-view cameras. In 2021, NHTSA opened an investigation into whether Ford was slow to recall more than 620,000 vehicles for faulty cameras. Recalls Ford Lincoln Safety Crossover SUV

Ford faces class-action lawsuit for selling vehicles without brake override systems

A total of 20 Ford customers are suing the automaker in a class-action lawsuit for selling vehicles "vulnerable to unintended acceleration." According to Reuters, the suit names 30 models built between 2002 and 2010 with electronic throttle control systems but without a brake override system. Those include the 2004-2012 F-Series pickups and the 2005-2009 Lincoln Town Car. Adam Levitt, a partner with the law firm of Grant & Eisenhofer says the plaintiffs in the case want "to be compensated for their economic losses by having overpaid for cars that contained defects." Levitt contends that the plaintiffs would not have bought their vehicles or paid less for them had they known there was no brake override system in place.
Ford began installing brake override systems in its vehicles beginning in 2010. In response to the lawsuit, Ford has pointed to research by the National Highway Traffic Safety Administration that indicated that unintended acceleration is mostly caused by driver error, saying in a statement that, "NHTSA's work is far more scientific and trustworthy than work done by personal injury lawyers and their paid experts."
Belville et al v. Ford Motor Co. will be heard in US District Court in the Southern District of West Virginia.