1997 Ford Econline 150 Cargo Van on 2040-cars

Auto blog

Ford recalls nearly 200,000 Expeditions and Navigators for fire risk

Ford is recalling 2015-2017 Expeditions and 2015-2017 Lincoln Navigators because the front blower motor could fail and cause a fire. In total, 198,482 Expeditions and Navigators will be recalled. In the official recall documents posted by NHTSA, Ford says that it “has not identified the cause of this condition.” However, Ford also says it is currently aware of 25 fire allegations related to the blower motors on these vehicles. Despite not strictly identifying the cause of blower motor fires, Ford put forth a theory in its fieldwork analysis of the issue.  “In June 2022, based on component analysis, Ford Engineering theorized that a mispositioned blower motor brush holder spring could cause an internal short or localized heating of the brush spring or holder. It is believed that when a fire initiates on the blower motor, it does so at the positive brush holder location. The variable blower controller would remain operational and there would be no signs of an overheated relay. Field data indicates that this concern typically occurs at a higher time in service, and on vehicles with higher mileage.” Since the blower motor is located on the passenger side interior behind the glovebox, the fires that start are interior fires. Ford isnÂ’t aware of any accidents related to this issue, but there is one claim of burnt hands and fingers as a result of a fire. According to Ford, warning signs of an impending fire or failed blower motor include an inoperative fan, burning smell and/or smoke from the instrument panel vents while the vehicle is on. To remedy this situation, Ford is recalling the affected SUVs and replacing the blower motor assembly with a revised part. The new part uses a blower motor assembly design utilized on other applications. If folks with these SUVs experience any symptoms of blower motor failure before the new part becomes available, Ford says they can take their vehicle to the dealer to have it replaced with a part of the same design. Once the redesigned part becomes available, the dealer will then swap it in. Owner notification letters are expected to begin on September 12 this year. Related video: This content is hosted by a third party. To view it, please update your privacy preferences. Manage Settings.

Ford celebrates 1 millionth Mustang built at Flat Rock

Yesterday, the Ford Mustang turned 49 years old, and Ford didn't miss the opportunity to celebrate the one millionth version of the Mustang rolling off the assembly line at the Flat Rock Assembly plant. Production of the Mustang at Flat Rock coincided with the fifth-generation design launching in 2004, and the one millionth car was the car shown above, a 2014 GT convertible painted in Ruby Red.
In total, Ford has sold more than 8.5 million Mustangs since the original car went on sale, but some of the key milestones over the car's nine years at Flat Rock include the Shelby GT-H, Bullitt, Boss 302 and, of course, the 662-horsepower Shelby GT500. Scroll down for a press release celebrating Flat Rock's milestone Mustang.

Former Cadillac boss Butler takes Ford tech job

When Don Butler made the surprising decision to leave his post as Cadillac's VP of global strategic development, it was a surprise. Citing a desire to "recalibrate, reassess my priorities" in that August announcement, it wasn't entirely clear where Butler - a virtual General Motors lifer after spending nearly 30 years with the company - would end up. Turns out he took a trip to Dearborn.
Butler has taken a position in the newly created position of Executive Director of Connected Vehicles and Services at Ford, where he'll be responsible for the Blue Oval's global connectivity strategy. "Not only does Don understand the connected car landscape, but probably just as important, he understands customer expectations," said Raj Nair, who, as Group Vice President of Global Product Development, is Butler's new boss. "Having a leader with technology experience both inside and outside the industry is a rare combination - we're excited to have Don join our team."
As Ford has received its fair share of flak for the sometimes recalcitrant MyFord Touch infotainment system and its Sync voice-controls, it appears that Butler has his work cut out for him.