Deep Red 7 Passenger Mini Van/family Car on 2040-cars

Auto blog

GM executive chief EV engineer says reducing cost of plug-in vehicles is 'huge priority'

As we know, another major automaker investing heavily in electrified vehicles is General Motors, and it's doing things much differently than rivals BMW, Ford or Nissan. The Chevrolet Volt extended-range EV is a modest seller at its $35,000 sticker price but a huge hit with owners. The Chevy Spark BEV, still in limited availability, puts smiley faces on its owners and drivers. The just-introduced Cadillac ELR, a sharp-looking, fun-driving $76,000 luxocoupe take on the Volt's EREV mechanicals, has admittedly low sales expectations. With this interesting trio in showrooms and much more in the works, the third vehicle electrification leader I collared for an interview at Detroit's North American International Auto Show (see #1 and #2) was Pam Fletcher, GM's executive chief engineer, Electrified Vehicles. ABG: Why do your EREVs need four-cylinder power to extend their range when BMW's i3 makes do with an optional 650 cc two-banger? "We designed [the Volt and the ELR] to go anywhere, any time" - Pam Fletcher PF: I get that question all the time: why not something smaller? You don't really need that much. You use the electric to its ability, then you just need to limp. But we designed those cars to go anywhere, any time, and we don't want their performance to be compromised. If you're driving through the mountains, we don't want you to be crawling up grades, or to be limited on any terrain. So it's optimized to be able to travel literally the biggest grades and mountain roads around the globe at posted speeds. Because what if you can't? Another good reason: when the engine is on, you have to run it wide open throttle, max speed, most of the time. And while we can do a lot with acoustics, and the ELR has active noise cancelation, a small-displacement, low cylinder-count engine at high speed, high load all the time isn't something you want to live with. That's how we came up with the balance we did among the key factors of performance, NVH [noise, vibration and harshness] and range. ABG: Where you go from here? Is the range-extender engine due for an update? PF: We know and love the current Volt, and there is still a lot of acclaim about it, so we think it's a good recipe. But we are heavily in the midst of engineering the next-generation car, which I think everyone will love and be excited about.

Consumer Reports criticizes small turbo engines for misleading performance, fuel economy claims [w/video]

Consumer Reports has taken aim at at small-displacement, forced-induction engines, saying the powerplants don't manage to deliver on automaker fuel economy claims. Manufacturers have long held that smaller, turbocharged engines pack all power of their larger displacement cousins with significantly better fuel economy, but the research organization says that despite scoring high EPA economy numbers, the engines are no better than conventional drivetrains in both categories. Jake Fisher, director of automotive testing for Consumer Reports, says the forced induction options "are often slower and less fuel efficient than larger four and six-cylinder engines."
Specifically, CR calls out the new Ford Fusion equipped with the automaker's Ecoboost 1.6-liter four-cylinder engine. The institute's researchers found the engine, which is a $795 option over the base 2.5-liter four-cylinder, fails to match competitors in acceleration and served up 25 miles per gallon in testing, putting the sedan dead last among other midsize options.
The Chevrolet Cruze, Hyundai Sonata Turbo and Ford Escape 2.0T all got dinged for the same troubles, though Consumer Reports has found the turbo 2.0-liter four-cylinder in the BMW 328i does deliver on its promises. You can check out the full press release below. You can also read the full study on the Consumer Reports site, or scroll down for a short video recap.

2015 Chevrolet SS Review [w/video]

The Chevrolet SS is one of the best cars no one's buying. It's a Bowtie-badged version of the Australian Holden Commodore with a 6.2-liter LS3 V8 under the hood. It's got a six-speed manual transmission, General Motors' sophisticated Magnetic Ride Control suspension, and rear-wheel drive. It's a fullsize sedan that comes with every possible amenity you could want. And it's less than $50,000. Chevrolet sold 2,479 SS sedans in 2014. That means it was outsold by every other vehicle the automaker offers, even the police fleet-only Caprice. (I'm only talking about cars that were on sale for the full 2014 calendar year, of course.) The aforementioned manual transmission and MRC suspension were added for 2015, but it's not clear if that's helping. The SS is down 7.7 percent through June of this year, compared to 2014's numbers. But hey, at least it's finally outselling the Caprice. What a damn shame. Granted, GM only planned to sell a few thousand of these each year, but as enthusiasts, this a car we should be gobbling up. It's the closest we'll get to a four-door Corvette, and with the 2015 model year updates, that statement is more true than ever. People often mistook the SS for a Malibu. "Is that a rental car?" Yikes. Aside from the manual gearbox and magnetorheological suspension, the SS is largely unchanged through its year and a half of sales. But that's no bad thing – we were thoroughly impressed with the SS when we first tested it at the end of 2013. Outside, the SS looks the same, which is a bummer. It is not an attractive car, and the chrome brightwork on the side vents and wheels doesn't help. That said, the sedate styling puts it under the radar – more so than competitors like a Dodge Charger 392, anyway. But maybe it's too under the radar. Even in the new, "Some Like It Hot Red" color (yes, really), photographer Drew Phillips reports that people often mistook the SS for a Malibu. "Is that a rental car?" Yikes. Exterior styling is our only gripe with the SS. Moving inside, there's a lot to like. This is easily one of Chevy's nicest, well thought-out interiors (thanks, Holden), with premium materials and tons of equipment. The Chevy MyLink infotainment system carries over, and now features 4G LTE and wifi connectivity. The touchscreen is a bit slow to respond, but otherwise, it's bright, well organized, and packed with functionality. This is easily one of Chevy's nicest, well thought-out interiors.