Green Truck, Wide Bed, 67, C-10, Used on 2040-cars

Auto blog

The real costs of keeping a Chevy Volt on the road

The release of the new, 2016 Chevy Volt is sure to bring a surge of used electric vehicles to the market as early adopters trade their older models in. Many of these cars are selling for a fraction of their original price, thanks in part to federal and state incentives that lowered the initial cost to the first owner, which opens these cars up to a whole new class of consumers. While the prices are getting attractive, potential buyers are still hesitant to buy a used EV due to uncertainty about service and repair costs, but there may be some good news on the horizon. The Chevy Volt comes with a battery warranty that is good for at least 8 years and 100,000 miles, but many of the Volts popping up on the market have passed that 100,000-mile mark. The threat of needing a new battery can be a deterrent, especially with some dealers quoting prices as high as $34,000 for a full "drive motor battery replacement." That sum is more than the MSRP of a 2016 model. Some of the fear of EV maintenance and repair comes from the mystery of the individual pieces that make up the drivetrain and charging system. If we take a look at the Volt in terms of analogs to a traditional internal-combustion vehicle, the outlook becomes a little more friendly. The Volt battery pack consists of three lithium-ion modules in a T-shaped arrangement, each of which can be serviced individually. Module 1 is made up of 90 cells and corresponds to GM part number 22954462, which retails for $3,258.33; module 2 is made up of 72 cells and corresponds to GM part number 22954463, which retails for $2,930.00; lastly, module 3 is made up of 125 cells and corresponds to GM part number 22954464, and retails for $4,933.33. These part numbers have been added to the dealer order systems but have not shown up in the distribution centers at this time. Although all three of the modules add up to a fairly large $11,121.66 total and are still on hold for dealer ordering, the good news is that in most cases these battery cell modules do not need to be replaced. There are many other individual pieces mounted on the battery pack that are serviceable, such as the Battery Energy Control Modules (BECM) and the Battery Interface Control Modules (BICM). These modules control and monitor the battery packs and charging system and have been known to fail while the lithium-ion battery cells are not at fault. Some have been replaced under warranty, but if you are stuck buying one they run about $255 a piece for the part.

Recharge Wrap-up: Ford HQ gets giant solar array, Chevy City Express gets 24 MPG city

Ford will be building Michigan's largest solar array at its Dearborn headquarters. With funding from DTE Energy, the solar carport will provide covered parking, as well 30 charging stations for electric vehicles. The array is expected to generate 1.13 million kWh per year for Ford's operations, and offset 794 metric tons of carbon emissions. Read more in the press release below. Chevrolet announced the fuel economy for the 2015 City Express, at 25 mpg combined. The cargo van is rated at 24 mpg in the city, and 26 mpg on the highway. Chevy credits the van's inline four-cylinder engine and continuously variable transmission for its impressive city mileage. For its customers - which are mainly businesses - "The fuel economy of the City Express will help stretch their dollar at the pump and give them the flexibility to invest the savings back into their business," says Chevrolet's Ed Peper. The City Express starts at $22,950. Read more in the press release below. Engineers at the University of Wisconsin have developed an efficient engine that runs on a diesel-gas blend. The engine, which uses a computer to control the blend proportions, is about 15 percent more efficient than the any diesel engine according to mechanical engineering professor Rolf Reitz. The team has put the experimental reactivity controlled compression ignition (RCCI) engine in a demonstration car - a 2009 Saturn. "This vehicle can do 50 miles per gallon," says Reitz, who believes the system could be improved further. Read more at Wisconsin Public Radio. The Southeast Alternative Fuel Conference and Expo will take place in October in Raleigh, North Carolina. Held at the NC Clean Energy Technology Center from October 22-24, the event will feature a variety of exhibitors, speakers and, most importantly, alternatively powered vehicles. "The three day conference will be a one-stop shop for fleet and transportation related decision makers to learn about return on investment, efficiency and alternative transportation fuels such as biodiesel, electricity, ethanol, propane and natural gas," says Anne Tazewell of the NC Clean Energy Technology Center. If you can't make it to Raleigh for the Expo, you can still enter to win a free two-year lease of a Nissan Leaf at the Center's website. Learn more about the event in the press release, below.

Watch this time-lapse build of the Chevy SS for NASCAR

There's only about a week left until we get our first look at the production version of the 2014 Chevrolet SS sedan, but Chevrolet NASCAR teams have been looking at the race version of the car all winter. Autoweek has posted a really neat time-lapse video showing just a portion of what it takes to build one of NASCAR's new Gen6 stock cars.
Though the video is quite brief, it does show almost the entire build process starting with just the car's nose, and it gives us a good look at how integral the template is to the final product. As a bonus, Hendrick Motorsports also provided some videos showing two of its teams performing pit stop tests over the winter. The second video shows some of the more detailed aspects of the racecar's rear end, including the stock-looking trunk cutout and a newly mandated rear bumper extension that will be used on super speedways like Daytona and Talladega.
To see what Team Chevy has been up to all off-season, check out all three videos posted after the jump.