G20 Conversion Van, 98k Miles, New Fuel Pump, Matching Tires, No Major Flaws on 2040-cars

Auto blog

2016 Chevy Volt arrives with 50-mile EV range, 41 mpg [w/ video]

Let's start with the numbers. The 2016 Chevy Volt will have an all-electric range of 50 miles from a new, 18.4-kWh lithium battery. It will get 41 miles per gallon (combined) once the battery runs dry and have 102 MPGe. Oh, and it has five seats, sort of. To compare, today's four-seat 2015 Volt has a 38-mile range from a 17.1-kWh battery in a powertrain that offers 37 mpg and 98 MPGe. So, across the board, there are notable improvements. Now that that's out of the way, let's talk story. General Motors will unveil the new Volt at the Detroit Auto Show later today, but it's been talking about how this new version – the first major plug-in hybrid vehicle to get a serious redo in the modern era – was crafted with reams and reams of data from first-gen Volt customers. At a preview event for journalists last week, GM executive chief engineer Pam Fletcher told Autoblog that these owners "gave us the recipe" to make the second-gen model. At the top of the request list was more range (check), more "fun-to-drive" behavior (check?) and a smoother and quieter experience (we'll assume a check here, given that the new 1.5-liter four-cylinder – the first North American application of this new engine family – should offer more power with less noise than the previous 1.4-liter, four-cylinder powerplant). Other customer-driven changes in the new Volt include a different place to store the charging cable (in the side of the trunk instead of under the load floor) and a new brake system with improved blended regenerative braking feel as well as driver-selectable regen levels. The requested 50-mile range comes from a new, lighter battery that has increased capacity from fewer cells (192 vs. 288) and a simplified control architecture. Along with the new battery, the electric drive unit is a two-motor deal that is up to 12 percent more efficient and 100 pounds lighter, while also being "tremendously smaller," notes Fletcher. It offers 294 pound-feet of torque and a maximum 149 horsepower of "motoring power" delivered to the wheels. GM says it has worked hard to reduced the amount of rare earth materials in these motors, and one of them doesn't use any at all. The new powertrain offers improved acceleration times, as well. The 2016 Volt can go from 0 to 60 miles per hour in 8.4 seconds, a seven-percent improvement, while the 0-30 mph time has been improved by 19 percent, down to 2.6 seconds. The new Volt is more conventional looking, but certainly not completely ordinary.

Chevrolet Captiva looks mildly refreshed and ready for family duty

We showed you Chevrolet's major debut yesterday, the 2014 Corvette Stingray Convertible, but General Motors is making a big push for Bowtie consideration in Europe, so it's also introducing the updated Captiva crossover here at the Geneva Motor Show.
While still based on the same platform as North America's fleet-only Captiva Sport (which is effectively a rebadged Saturn Vue), the Captiva is available in both five- and seven-seat iterations, and it looks far more modern. That's particularly the case with this updated model, which features revamped front- and rear ends that include restyled bumpers, grilles and LED taillamps, among other changes.
As before, the midsize Theta-platform CUV will be available in both front- and all-wheel drive, and is expected to carry a range of four- and six-cylinder gasoline and diesel engines. Important US programming note: Chevrolet sources tell us that America's Captiva Sport will not receive these updates.

Chevy 'committed to marketing Bolt the right way'

The 2015 edition of the annual AltCar Expo in Santa Monica, CA in September was a relatively quiet affair. Attendance felt light compared to previous years. But that didn't mean there wasn't something happening that might have just as big an impact on the plug-in scene as anything that's ever happened in previous years at the Santa Monica Convention Center. I say this because of what GM's Shad Balch told me about Chevy's plans to market the upcoming Bolt electric car. This is GM's next-gen electric vehicle, which will have a roughly 200-mile range and may cost about $30,000 after tax incentives (maybe). To say he's excited to start selling this car is an understatement. Set aside the obvious challenge Chevy will have with cars named both the Volt and the Bolt, especially when some languages exchange the pronunciation of the letters B and V. Set aside the fact that, for now, Balch is dealing with his own company actively advertising against the product he's trying to get people excited about. Balch, GM's manager of new product and public policy communications, is tremendously positive about the Bolt's chances in the marketplace when it arrives in 2017 or 2018. "Driving an EV is, in every proof point, better than a gas-powered car, except for charging." - Shad Balch AltCar and the concurrent National Drive Electric Week represented the Bolt's West Coast debut, and Balch told me that the car's arrival in California shows how "Detroit recognized that they need to send it out to their number one market." The car's appearance outside of the Motor City was "The most encouraging part for us out here, being in the market ... to be able to explain that we are committed to marketing this car the right way. ... We're trying to make that known as much as possible, because that is the number one criticism that we hear. That's why events like these are so important, because we can't wrap up into a 30-second spot what these cars are capable of. I can't even explain it to you in 10 minutes what it's like. But the thing is, driving an EV is, in every proof point, better than a gas-powered car, except for charging." Now, there's a fairly decent chance that GM will hit the 250,000-vehicle limit for the $7,500 federal tax incentive right about when the Bolt comes to market, so I had to ask how the Bolt gets marketed if the price tag jumps up a few thousand dollars. Balch was straightforward. "Well, we would sell fewer cars," he said. "It's pure and simple. ...