1968 Chevelle Ss396 Real 138 True Survivor on 2040-cars

Auto blog

GM tells 2021 Chevy Express and GMC Savana owners to park vans outside due to fire risk

GM is telling owners of certain 2021 Chevrolet Express and 2021 GMC Savana work vans to park them outside and away from other vehicles and structures due to a fire risk. Additionally, the company is recalling 10,154 of the vans it believes to be at risk of catching fire. The breakout is 7,891 for Chevy and 2,223 for GMC.  Only vehicles equipped with the 6.6-liter V8 (the new-for-2021 engine option) are included in the recall, and it’s limited to vans produced on or prior to December 7, 2020. The problem stems from some anti-rotation tabs on the positive battery terminal that are too close to a fuse block assembly attachment post. This lack of clearance could cause the tabs to come into contact with the fuse block, causing a short circuit. GM points out that a short-circuit of this nature could cause battery drain or lead to a fire under the hood. Your warning for the time being will come in the form of a low battery voltage warning, or you might just wake up with an unexpected dead battery. GM says that it first opened an investigation into this problem on January 26 this year after it was notified of an underhood battery fire on a 2021 Express. The investigation found three other underhood fires and concluded that these fires were originating from the positive battery cable attachment near the fuse. This recall was officially posted on March 11 this year, and the National Highway Traffic Safety Administration just sent a notification out to the media yesterday. The fix is a relatively simple one. Dealers are going to remove a portion of the anti-rotation tab on both positive battery cable terminals near the fuse block assembly attachments. This increases the clearance and eliminates the risk of fire, GM says. The job will be done under warranty, and GM says it will begin contacting owners for recall work on May 3 this year. Recalls Chevrolet GMC Safety Minivan/Van Commercial Vehicles

GM executive chief EV engineer says reducing cost of plug-in vehicles is 'huge priority'

As we know, another major automaker investing heavily in electrified vehicles is General Motors, and it's doing things much differently than rivals BMW, Ford or Nissan. The Chevrolet Volt extended-range EV is a modest seller at its $35,000 sticker price but a huge hit with owners. The Chevy Spark BEV, still in limited availability, puts smiley faces on its owners and drivers. The just-introduced Cadillac ELR, a sharp-looking, fun-driving $76,000 luxocoupe take on the Volt's EREV mechanicals, has admittedly low sales expectations. With this interesting trio in showrooms and much more in the works, the third vehicle electrification leader I collared for an interview at Detroit's North American International Auto Show (see #1 and #2) was Pam Fletcher, GM's executive chief engineer, Electrified Vehicles. ABG: Why do your EREVs need four-cylinder power to extend their range when BMW's i3 makes do with an optional 650 cc two-banger? "We designed [the Volt and the ELR] to go anywhere, any time" - Pam Fletcher PF: I get that question all the time: why not something smaller? You don't really need that much. You use the electric to its ability, then you just need to limp. But we designed those cars to go anywhere, any time, and we don't want their performance to be compromised. If you're driving through the mountains, we don't want you to be crawling up grades, or to be limited on any terrain. So it's optimized to be able to travel literally the biggest grades and mountain roads around the globe at posted speeds. Because what if you can't? Another good reason: when the engine is on, you have to run it wide open throttle, max speed, most of the time. And while we can do a lot with acoustics, and the ELR has active noise cancelation, a small-displacement, low cylinder-count engine at high speed, high load all the time isn't something you want to live with. That's how we came up with the balance we did among the key factors of performance, NVH [noise, vibration and harshness] and range. ABG: Where you go from here? Is the range-extender engine due for an update? PF: We know and love the current Volt, and there is still a lot of acclaim about it, so we think it's a good recipe. But we are heavily in the midst of engineering the next-generation car, which I think everyone will love and be excited about.

Vert-A-Pac train cars kept your Chevy Vega's price in check

Our apologies to those who've seen this before, but for the rest of the class, how awesome are these pictures of the Vert-A-Pac shipping system General Motors came up with to ship the Chevrolet Vega back in the 1970s? Developed along with Southern Pacific Railroad, GM was able to double the amount of Vega models it could ship by packing them into the unique storage cars vertically.
At the time, rail cars could fit 15 vehicles each, but Chevrolet was able to lower shipping costs by making it possible to ship 30 Vegas per rail car, in turn allowing the price of the Vega to remain as low as possible. Each rail car had 30 doors that would fold down so that a Vega could be strapped on, and then a forklift would come along and lift the door into place. All the cars were positioned nose down, and since they were shipped with all of their required fluids, certain aspects had to be designed specifically for this type of shipping, including an oil baffle in the engine, a special battery and even a repositioned windshield washer reservoir. See for yourself in our image gallery above.