1984 Chevy K5, on 2040-cars

Auto blog

How GM engineers are using diaper 'snow' to keep you warm

Testing how snow affects General Motors' vehicles isn't really a problem right now for the company's engineers, but in the dog days of summer the process isn't exactly easy. The only real option is for them to book time at the automaker's climatic wind tunnel. However, a flash of brilliance from an engineer allows snow to be simulated regardless of the temperature outside, and the discovery is all because of his daughter's wet diaper. The realization came to GM Thermal Systems engineer Nicholas Jahn while he was swimming with his daughter and noticed how her diaper ballooned in size in the water. He found out the substance that makes this possible is called sodium polyacrylate. When the material gets wet it grows and forms fluffy flakes that are a close imitation of snow. Best of all, the stuff can be prepared easily any time of the year, and it's reusable. The engineering team uses the material to test the effectiveness of the heating systems of GM's vehicles. They spread the sodium polyacrylate over the inlets at the base of the windshield to obstruct the airflow and then crank the heater. After some time, they can see how much is being sucked into the system and design more efficient systems in the future. See how the process works in the video above and read about the diaper discovery in GM's press release below. Diapers Change Chevy Cruze Winter Warm-up Time GM validation engineer uses diaper material "snow" to reduce frigid drives 2015-01-06 DETROIT – An item commonly found on an infant's changing table is helping General Motors' engineers simulate snow year round, ensuring heating systems in cars like the 2015 Chevrolet Cruze can quickly and efficiently warm its interior. Packed snow can prevent air from entering the inlet panel at the bottom of the windshield, obstructing the flow of air into the heating system and reducing the amount of air it can push out. This can lead to less efficient warming of the car's interior and windshield defrosting. "The last thing anyone wants to do when it's freezing cold out is scrape their windshield," said Nicholas Jahn, GM Vehicle Thermal Systems engineer. "The testing we perform on the Chevrolet Cruze with the diaper material allows us to maximize the car's heating capabilities." Ironically, Jahn stumbled upon his diaper-based testing method in the middle of summer. During a swim with his daughter, he noticed her diaper multiplied in size when it came into contact with water.

Camaro spy shots show subtly different grille, front fascia

It looks like there some changes in store for the Chevrolet Camaro - the only thing is that we just don't know what Chevy has up its sleeve. Looking at these spy shots, we'd initially be inclined to think that there is just a minor facelift or a new special edition, but upon closer inspection, there are a few oddities about this car that definitely have us intrigued.
The most obvious difference on this prototype is the slightly restyled front fascia with a smaller lower air inlet and the two-bar grille. Then we get to some of the car's mysterious details. For starters, this fascia has the SS vent above the grille, but it looks to be blocked off. Granted this could just be a one-off piece used for testing. What really piqued our interest was at the rear of the car where it has quad exhaust outlets that are used on the ZL1. Could this be the LS7-powered Camaro that we reported on back in December?
At this point, your guess is as good as ours as to what we're looking at here, so let us know in the comments what you think this could be.

EcoCar3 will convert Camaro to bitchin' eco rides

In the 47-year-history of the Chevrolet Camaro, there have been countless college-age kids spending a ton of time getting under the hood and souping 'em up. Now, General Motors is adding a twist to the concept by donating 16 Camaros for the EcoCar challenge that puts university teams together to wring out better fuel-efficiency out of various vehicles. No word on whether there will be donuts on anyone's lawn, as suggested by 80's punks the Dead Milkmen, but the idea's never a bad one. EcoCar3 will feature 16 teams such as Arizona State, Penn State, Ontario's University of Waterloo and, of course, Detroit's Wayne State University. They'll spend the next four years "[reducing] environmental impact, while maintaining the muscle and performance expected from this iconic American car," as the EcoCar organizers say. The goal is to maintain body design and safety standards while boosting efficiency and lowering emissions, but the actual process is far more complicated than that description suggests. The California Air Resources Board (CARB) and Bosch are among the sponsors of the contest, which is also put on by the US Department of Energy and managed by Argonne National Laboratory. Penn State won Year Two of the three-year EcoCar 2 competition with its E85 plug-in hybrid electric vehicle converted out of a Chevy Malibu. The grand-prize winner of EcoCar2 will be announced in June. Check out the EcoCar3 website and see the announcement video below for more details. This content is hosted by a third party. To view it, please update your privacy preferences. Manage Settings.