2003 Volkswagen Beetle Gl 5spd Manual Low Miles No Reserve on 2040-cars

Auto blog

Crash test videos show how rust compromises safety

These recently released Swedish videos serve as a reminder that rust isn't just a cosmetic flaw, when it comes to cars. The insurance company Folksam and the homeowner organization Villaagarnas Riksforbund gathered examples of two relatively popular, but by now rusty cars, and then performed crash tests with them at the Thatcham Research facility in Britain. The results are sobering. The rustier cars chosen for the tests were first-generation Mazda6s, cars that have a reputation for early-onset rust in salty surroundings, such as the Nordic countries in Europe or the Salt Belt in the U.S. The cars in the other end of the spectrum were fifth-generation Volkswagen Golfs, which thanks to their body treatment only really start to show rust at over ten years old. But rust isn't just on the surface, it goes bone deep. While the Mazda did decently well in Euro NCAP testing as a new car, there's now a 20 percent higher risk of death in the 2003-2008 Mazda due to the degradation of its bodyshell. In the rusty car, the chassis rail separates from the floor, the footwell ruptures, the sill gives way, the seat mountings move and the dummy's head hits the B-pillar; all important failures, despite Thatcham saying the cars actually performed better in the crashes than they expected with all the rust. But still, the corroded structure isn't able to transmit loads in the way it was originally designed to do. This content is hosted by a third party. To view it, please update your privacy preferences. Manage Settings. The Golf does significantly better — despite rust flakes flying when the Golf hits the wall — as the years have only caused it to lose a single point. An important thing to remember is that the cars aren't tested in comparison to corresponding new, 2018 cars: the tests are in reference to the crashworthiness standards in place when they were new. The cars' airbags inflate like they were supposed to, but on the Mazda the dummy's head bottoms out the airbag due to the car's structure failing, meaning the airbag cannot perform as designed. Driven cautiously, an older car is still mostly fine for driving around. But tests like these remind us that it's not enough that a car runs and drives, if the body has turned into Swedish knackebrod. And if you repair the visible rust and the structure underneath remains as compromised as ever, there's an ugly truth under all the bondo. Perhaps it isn't such a bad idea to have yearly roadworthiness inspections.

Audi's Project Artemis woes could delay range of VW Group EVs

Two years ago, Audi's then new CEO Markus Duesmann announced his first big initiative called Project Artemis. The plan's marquee component is "to implement a new lighthouse project for Audi in record time," being "a highly efficient electric car scheduled to be on the road as early as 2024" on a brand new platform that would be shared with Porsche and Bentley. An ex-VW and -Porsche man named Alex Hitzinger, who'd also spent time at Apple working on the tech company's electric car, was brought on board to lead Project Artemis and come up with new ideas. Parent Volkswagen Group said it wanted to become "as agile as in a racing team," removing the bureaucratic molasses and bottlenecks interfering with getting the best product on the road in the best time. However, in any grand venture, failure comes before success. Automobilwoche reports that Artemis is struggling through issues large enough to push the product plans back by years. The issue, as it was with the ID.3 lineup on the eve of that car's launch, is software. Well, that's the latest, largest problem; Artemis has already been through copious struggles before getting to the software bit. Two months after Hitzinger came on, in December 2020, VW raised its EV volume target from 50% to 70% by 2030. That necessitated a rethink of the VW Group's entire platform strategy considering the far greater production scale. Hitzinger only lasted six months in the job, ousted in May 2021, supposedly because Audi believed his ideas were "not suitable for profitable series production" among other reasons. By that time, the pace of software development was already said to be six months behind schedule, with the Car.Software division working on VW.OS 2.0 "not yet running at the speed hoped for." Internal frictions were noteworthy and costly as well. VW's commercial division plant in Hanover was meant to build Artemis vehicles for Audi, Porsche and Bentley, but Automobilwoche reported in January of this year that Porsche paid a ""small three-digit million amount" — like $100 million or so — to get out of the deal mandating its vehicles come from the Hanover facility.    So Audi effectively brought Artemis in-house to lead vehicle development, and Car.Software turned into Cariad to get VW.OS and VW.AC, which stands for Automotive Cloud, to market.  The first Audi vehicle under Project Artemis was planned to arrive by the end of 2024, a production version of the Grandsphere concept.

VW going turbo-only in 3 to 4 years

This really was a matter of when, rather than if. Volkswagen will apparently be the first manufacturer to phase out naturally aspirated engines in favor of turbocharging its full slate. VW is kind of responsible for ushering in this push towards small-displacement, turbocharged engines that's taken the industry by storm. When it dropped its direct-injection, 2.0-liter turbo in the 2005 GTI it demonstrated that strapping an iron long to an engine can enhance the powertrain as a whole. VW made fuel economy gains, while also giving a linear, non-laggy turbo experience that it has replicated, model-after-model, to this day.
Speaking with The Detroit News, Volkswagen's executive Vice President of Group Quality, Marc Trahan, told the paper that, "We only have one normally aspirated gas engine, and when we go to the next generation vehicle that it's in, it will be replaced. So three, four years maximum."
Really, it's hard to get teary-eyed about either of these engines going away. VW has access to smaller powerplants that could easily match the performance of the 2.5 five-cylinder and the 3.6 V6, while gobbling up less fuel and providing a better driving experience. What we are sad about is that a similar statement about the extinction of NA engines came from the Vice President of Powertrain Engineering at Ford, Joe Bakaj. We'd certainly get teary-eyed over a world without Ford's excellent 5.0-liter V8.