Toyota 4runner Sr5 4wd Leather Sunroof Power Rear Window Fully Loaded No Reserve on 2040-cars

Auto blog

US expands probe into ZF-TRW airbag failure-to-deploy to 12.3 million vehicles

DETROIT — U.S. auto safety regulators have expanded an investigation into malfunctioning airbag controls to include 12.3 million vehicles because the bags may not inflate in a crash. The problem could be responsible for as many as eight deaths. Vehicles made by Toyota, Honda, Kia, Hyundai, Mitsubishi and Fiat Chrysler from the 2010 through 2019 model years are included in the probe, which was revealed Tuesday in documents posted by the National Highway Traffic Safety Administration. It involves airbag control units made by ZF-TRW that were installed in the vehicles. The control units can fail in a crash, possibly because of unwanted electrical signals produced by the crash itself that can disable an air bag control circuit housed in the passenger compartment, according to NHTSA documents. The electrical signals can damage the control circuit, the documents say. ZF, a German auto parts maker which acquired TRW Automotive in 2015, said in a statement that it's committed to safety and is cooperating with NHTSA and automakers in the investigation. The case is another in a long list of problems with auto industry airbags, including faulty and potentially deadly Takata airbag inflators. At least 24 people have been killed worldwide and more than 200 injured by the inflators, which can explode with too much force and hurl dangerous shrapnel into the passenger cabin. The inflators touched off the largest series of automotive recalls in U.S. history involving with as many as 70 million inflators to be recalled by the end of next year. About 100 million inflators are to be recalled worldwide. On April 19, NHTSA upgraded the ZF-TRW probe from a preliminary evaluation to an engineering analysis, which is a step closer toward seeking recalls. So far, only Hyundai and Kia and Fiat Chrysler have issued recalls in the case. Four deaths that may have been caused by the problem were reported in Hyundai-Kia vehicles and three in Fiat Chrysler automobiles. NHTSA opened an investigation in March of 2017 involving the TRW parts in Hyundais and Kias. The upgrade came after investigators found two recent serious crashes involving 2018 and 2019 Toyota Corollas in which the airbags did not inflate. One person was killed. Jason Levine, executive director of the Center for Auto Safety, a nonprofit consumer group, said the ZF-TRW case shows the auto industry thus far has learned very little from Takata.

Toyota drops detail about 414-hp Hybrid-R concept powertrain

The Toyota Yaris Hybrid-R Concept has been teased already, offering up little glimpses and details of the Frankfurt-bound vehicle. And while those few, shadowy shots have been great, we've really wanted to know how this hatchback would deliver its promised 400-plus horsepower. Under hood sits a 1.6-liter, race-derived, direct-injection, turbocharged four-cylinder that powers the front wheels. Sounds peachy, but with 414 horsepower splashed across the page, we're going to need something more than a 1.6-liter, turbo four.
A supercapacitor, developed from the Toyota TS030 Hybrid Le Mans racer sits in place of a hybrid's traditional battery packs. The benefit, according to Toyota, is that power can be more rapidly absorbed and discharged than in a traditional battery system, like nickel metal-hydride.
The gas engine is joined by a trio of 60-horsepower electric motors. Two of the them power the rear wheels, while the third sits between the engine and the six-speed, sequential gearbox. Developing the same amount of power as the rear-axle motors, this centrally located motor channels power to the race-derived supercapacitor during braking, and ships extra grunt to the rear wheels under acceleration when the front wheels start to lose grip. Besides the distributive power of the central motor, the rear electric motors can adjust the amount of torque flowing to each wheel, much like a differential.

Toyota C-HR stays sharp from prototype to production

Scion is dead. While the troubled brand was given 13 years to make a case for itself, it never quite succeeded. And that's a shame, because we're pretty confident that this, the production-spec Toyota C-HR would have been one of its biggest hits. Instead, when it arrives in the US, it will be as a Toyota... where it will still likely be a big hit. The new small CUV made its debut after literally years of teasing concepts, the most recent of which was shown late last year in Los Angeles, where it was badged as a Scion. After seeing that car, it's quite clear that Toyota has strained itself to translate its style to the real world. Up front, there's clear inspiration from the Toyota Auris/Scion iM. But aside from the front, the C-HR's biggest inspiration appears to be the Nissan Juke. View 14 Photos It's like Toyota has tried to go even further, though. Its wheel arches are flared even more aggressively and they feed into a strong character line on the lower portion of the doors. In back, Toyota's designers seem to have just rotated the Juke's taillights 180 degrees while they sit below an extremely fast rear window. Said window is integrated into today's latest design trend, a floating roof. Mechanically, the C-HR rides atop Toyota's New Global Architecture, which is Japan's answer to Volkswagen's MQB architecture. Power comes from a hybrid drivetrain, good for a relaxed 120 horsepower. If you don't want hybrid power, Toyota will sell the C-HR with the Euro-market Auris' turbo 1.2-liter engine, but we almost certainly won't see that here in the US. Instead, American drivers will probably be left with nothing but a 2.0-liter, naturally aspirated four-cylinder. That engine will be exclusively paired with a continuously variable transmission that sends power to either the front- or to all four wheels. So there's Juke inspiration, but not in the driving character. Toyota says it will build the C-HR Hybrid in Turkey. We don't know if that facility will handle US-market vehicles or just Europe, but we wouldn't be surprised to see additional facilities come online to produce this stylish little bugger. Related Video: TOYOTA C-HR Toyota's Fresh New Take on the Crossover 2016 Toyota Motorshow Geneva Making its world debut at the 2016 Geneva motor show, the C-HR gives Toyota a powerful new presence in the crossover market.