2004 Saturn Vue on 2040-cars

Auto blog

Saturn Vue ignition issue was discussed three times before recall, new documents reveal

Despite the tens of millions of recalled vehicles this year, it's somewhat rare that we get a glimpse into what goes into deciding when to conduct one of these safety campaigns. New documents published by General Motors and the National Highway Traffic Safety Administration are giving us an interesting opportunity to see how the sausage is made and show the number of meetings it takes to declare a recall.
In early August, GM added about another 269,000 vehicles to its 2014 recall tally in the US when it announced a slew of new safety campaigns. Among them was a fix for the 2002-2004 Saturn Vue that covered 202,155 of them in the US. The problem was that the key could be removed from the ignition even when it wasn't in the "OFF" position, and that had caused two crashes and one injury, according to the automaker.
Where we start to see behind the veil is in the defect notice freshly released by NHTSA. It shows that GM began investigating more widely for ignition switches in April, shortly after the company expanded its ignition switch recall to a variety of Saturn products, among others, according to Automotive News. The automaker found 152 reports in the 2002-2004 Vue of vehicles rolling away or the key being removed out of a total population of 215,243 units worldwide.

NHTSA opens safety investigations into Toyota, GM and Honda crossovers

The National Highway Traffic Safety Administration is evidently keeping itself very busy these days, as the federal agency has just announced it is launching or renewing investigations into Toyota, Honda and General Motors crossovers.
2006-2008 model year Toyota RAV4 crossovers are under review for allegations of rear tie-rod rust which can result in failure. NHTSA also said it is probing some 35 complaints about 2005 Honda Pilot models with inappropriate activation of the vehicles' stability control system. The alleged malfunction can cause the vehicles to slow down or stop in bad unsafe situations. At the moment, NHTSA is reviewing a petition regarding the Pilot issue, a move that will determine whether it needs to open a full-blown investigation.
In addition, Saturn Outlook and GMC Acadia three-row crossovers built in 2007-2009 are getting looked at for "loss of low beam headlamp" function. One complainant said the wiring in his Outlook overheated and melted. NHTSA says it has received 415 complaints about the problem and a GM spokesman confirmed that the automaker already started a "Customer Satisfaction Program" in December to address the issue.

Junkyard Gem: 2008 Saturn Astra XR 3-Door Hatchback

GM's Saturn brand spent the first part of the 2000s shifting over to vehicles on global corporate platforms, then spent the second half of the decade increasingly flailing for relevance as The General itself struggled to stay upright. By 2008, prospects for Saturn— and the American economy in general— didn't look so great, but that was the first model year for the Saturn-badged Opel Astra in North America. The announcement that the axe would be falling on Saturn came the following year, soon after GM declared Chapter 11 bankruptcy, and so 2009 became the final year for the Saturn Astra. Some MY2010 Saturns were sold (the Sky, Outlook, and Aura), but the Astra shares the dubious honor of the shortest Saturn sales run with the long-forgotten Saturn Relay minivan. For this reason, I keep my junkyard eye open for discarded Astras, and finally found this very clean '08 three-door in a Denver self-service yard last week. The Astra could be purchased with three doors or five, in two very similar trim levels. This car is the three-door, which was available only in semi-high-zoot XR trim. I'm not sure if the Opel Astra got these GM "Mark of Excellence" fender badges, but all American-market 2005-2009 GM vehicles have them (not counting stuff bearing the crypto-GM Suzuki badge). I've got dozens of these badges glued to my garage wall, because why not? Just one engine was available in the Saturn Astra: a 1.8-liter Ecotec four rated at 138 horsepower. The Ecotec has proven to be an unusually reliable engine, but I suspect that this one died in some expensive manner (because the rest of the car looks so nice) and that's why the car is here now. The base transmission in the Astra was a five-on-the-floor manual, and that's what this car has. The four-speed automatic cost an extra $1,325 on an $18,375 car (that's about  $1,765 on a $24,475 car in 2022 dollars), so either the original purchaser of this car preferred three-pedal driving or was just a cheapskate. I haven't seen enough junkyard Astras to know if the manual transmission is very rare in these cars; the five-door I found a few years back had the automatic. Presumably, an American car shopper looking for the European-style driving experience of an Opel might prefer the manual. Built in Antwerp, Belgium! As this was just a rebadged Opel, the Astra did not have the standard GM radio faceplate found in everything from the Chevrolet Equinox to the Saab 9-3.