1999 Saturn Sc1, Excellent Daily Driver Lqqk! on 2040-cars

Auto blog

Saturn Ion steering probe closed by NHTSA

The National Highway Traffic Safety Administration has closed its investigation into faulty electric power steering motors affecting 334,728 Saturn Ions from 2004-2007, because General Motors has issued a recall for them. The group's research found that the part failed at a high rate in the vehicles.
GM recalled over 1.3 million vehicles a few weeks ago, including the Ion, because the power steering could suddenly fail. If broken, the cars could still turn, but it took greater effort. The automaker is also covering 96,324 2003 Ions with a lifetime warranty for their motors, but it's not immediately replacing them.
NHTSA opened its investigation into the motors in September 2011, and it found 4,787 complaints and 30,560 warranty claims that showed failure for the Ion alone. It estimated a complaint rate of 14.3 incidents per 1,000 vehicles and warranty claim rate of 9.1 percent. The investigation also found evidence of 12 crashes caused by loss of steering, two of which resulted in injuries.

303 Deaths Tied To Airbag Non-Deployment In 2 General Motors' Cars

At least 303 motorists died in car accidents after their airbags didn't deploy in now-recalled General Motors vehicles, according to a study released late last night. The Center for Auto Safety, a non-profit automotive watchdog, reviewed data from the Fatality Analysis Reporting System, and counted deaths involving the Chevrolet Cobalt and Saturn Ion, two vehicles at the heart of several ongoing investigations, to reach its conclusion. If the airbag non-deployments were the result of a faulty ignition switch that inadvertently turns them off, the death toll would be the largest in automotive history attributed to a single defect, surpassing the 250 deaths investigators linked to defective Firestone Tires more than a decade ago. The rising death toll would further amplify questions about why GM and federal safety regulators at the National Highway Traffic Safety Administration didn't act sooner to correct the problem. Safety advocates have said both GM and NHTSA failed to act in a timely fashion to alert motorists of the dangers posed by the dangerous defect, of which documents GM had knowledge of as early as 2001 and NHTSA knew about in 2007. "The question today for NHTSA is how so many ... death reports without an airbag deployment and so many FARS deaths without an airbag deployment failed to trigger an investigation," wrote Clarence Ditlow, the executive director of the Center for Auto Safety. "... For the people who died or were seriously injured in crashes, the answer comes too late." GM has acknowledged 13 deaths related to the problem, and says the number cited by the Center for Auto Safety study is "speculation." The review of FARS data, conducted by Friedman Research at the request of the Center for Auto Safety, looked at fatal cases in which airbags did not deploy but did not analyze the causes of the crashes. FARS information is raw data submitted to a national database by state and local authorities when fatal accidents occur. Last month, GM recalled 1.37 million cars in the U.S. because a faulty ignition switch had been inadvertently moving from the "run" position to the "accessory" position, turning off engines and systems that provide power to airbags. "Shame is not a strong enough word," said Lou Lombardo, the founder of Care for Crash Victims, another safety-minded nonprofit that advocates for accident victims. The results of the CAS study were first reported by the New York Times.

Report: GM temporarily restarts Saturn Outlook, Hummer H3 production

Saturn Outlook - Click above for high-res image gallery
Even though both the Saturn and Hummer brands are being phased out, General Motors has reportedly revived production of both the Outlook crossover and H3 SUV to meet consumer demands.
Last month, GM assembled 1,037 Outlooks at its Lansing, Michigan facility, which is where the crossover's Lamda platform stablemates (Buick Enclave, Chevrolet Traverse and GMC Acadia) are built. A spokesperson for GM states that production was reinstated to utilize the rest of the Saturn-specific material at the facility, and that the automaker will continue to assemble the Outlook for a few more weeks.