2005 Jeep Wrangler Unlimited Sport Utility 2-door 4.0l on 2040-cars

Auto blog

7 months later, Jeep 'trailer hitch' recall still stalled

For the past few years, Chrysler and its CEO, Sergio Marchionne, have gone head-to-head with the National Highway Traffic Safety Administration and its boss, David Strickland, over the government safety agency's request for Chrysler to recall almost three-million Jeep vehicles due to what NHTSA says is a safety issue that has caused at least 51 deaths. After a three-year investigation and Chrysler's initial refusal to issue a recall because it deemed the vehicles safe and built to the day's federal requirements, last summer, the two parties compromised on a "voluntary campaign" to inspect 1.56 million vehicles, those being the 1992 to 1998 Grand Cherokee and 2002 to 2007 Liberty.
Those vehicles were designed with their gas tanks between the rear axle and the bumper, and NHTSA says that in rear-end collisions, damage to the fuel tank has caused fires responsible for those 51 deaths. The compromise reached last summer was that Chrysler would inspect 1.56 million vehicles and, "if necessary, provide an upgrade to the rear structure of the vehicle." Practically speaking, that meant Chrysler would replace aftermarket trailer hitches, but would take no action if a vehicle had a factory-installed hitch or an aftermarket hitch from Mopar.
A report in The Detroit News says the "voluntary campaign" is just now getting under way, with Chrysler saying last week that the design of the replacement part had been finalized and it was tooling up "to deliver the required volume." Seven months later, still in question is whether NHTSA will crash-test the fix engineered by Chrysler, noteworthy because not only did the vehicles in question pass every safety standard necessary to be cleared for sale at the time, there are still questions (to those of us on the outside) as to how the Jeeps at issue fare among their peers in such incidents. Either way, Chrysler and NHTSA apparently still disagree on the efficacy of the remedy itself: the carmaker says it might help in low-speed crashes but not high-speed collisions, a position the NHTSA is at odds with. All of this means the campaign doesn't yet have an end in sight.

Chrysler Recalling Nearly 907,000 Cars, SUVs

Nearly 907,000 Chrysler, Dodge and Jeep SUVs and cars are being recalled for alternators that can fail and heated power mirror wiring that can short and cause minor fires. The recalls, posted Thursday by U.S. safety regulators, push the total number of recalls so far this year 544, totaling a record of more than 52 million vehicles. The largest of Thursday's recalls covers nearly 470,000 Jeep Grand Cherokees, Chrysler 300s, and Dodge Chargers, Challengers and Durangos from the 2011 through 2014 model years. The alternators can fail, causing the 3.6-liter V6 engines to stall unexpectedly. The problem also can cause the electrical system to fail, as well as knock out power-assisted steering, antilock brakes and electronic stability control. It can even cause fire or smoke, according to documents Chrysler filed with the U.S. National Highway Traffic Safety Administration. NHTSA opened an investigation into the problem in July, and Chrysler began its own probe in August. The company analyzed warranty complaints and alternators that had failed. The alternator generates electricity to recharge the battery and run other devices. Chrysler investigators traced the problem to heat fatigue in an alternator diode. Chrysler said it received 322 complaints about the problem, while 55 people complained to NHTSA. The company said it knows of one crash related to the problem, but no injuries or fires. The company will replace the alternators with upgraded versions for free. Owners will be notified in November. The company says customers who see warning lights or suspect a problem should contact their dealers. The recall affects cars and SUVs sold mainly in the U.S. and Canada, but some were sold in Mexico and overseas markets. The second recall covers almost 437,000 Jeep Wranglers from 2011 through 2013. Water can find its way into the heated power mirror wiring harness and cause corrosion. That can cause a short and could cause a minor fire and smoke, as well as cause loss of function of the mirror. The problem was discovered in February after three Wranglers in Canada were damaged. Chrysler says it has 26 complaints about the problem, but it knows of no fires, crashes or injuries. Dealers will move the wiring and install a protective shield to keep water out at no cost to owners, starting in December. Most of the Wranglers are in the U.S., Canada and Mexico, but more than 78,000 were sold overseas.

A hybrid Jeep Wrangler could be in the cards for new generation

Jeep could make a hybrid version of its iconic off-roader, the Wrangler, the head of the Jeep brand suggested in an interview with Autoblog. Speaking this week on the floor of the Detroit Auto Show, Jeep's global chief Mike Manley said "the hybridization could actually help Wrangler," noting it could improve torque distribution, a critical element for four-wheel drive vehicles. Manley added, "Electrification, absolutely. I could see Wrangler being a form of electric." The Jeep boss didn't offer further details, though a hybrid Wrangler has been rumored for years. The next-generation off-roader is due for the 2018 model year, which means a reveal is imminent. Hybrid technology would likely be used to assist the Wrangler's performance and efficiency, rather than as a total fuel-economy play. The next-gen Wrangler is expected to have LED lights, updated and more aerodynamic design, and greater use of aluminum. A turbo four-cylinder gasoline engine, a diesel engine, and an eight-speed automatic transmission are also among the powertrain rumors, though the diesel may be in jeopardy after the EPA accused FCA US of installing emission-control software on its EcoDiesels. Despite the changes, this new Jeep will be instantly recognizable as a Wrangler, Manley told us. "It's the icon of our brand." View 30 Photos Also heartening for enthusiasts, the Wrangler is getting a pickup variant built alongside the utility vehicle in Toledo, OH. Manley wouldn't speculate on a name, though it has a long list of historic choices. Jeep used "Comanche" on a Cherokee-based pickup from 1986-92 and had the Gladiator/J-Series for a larger truck from 1963-87. "Of course we could go back to one of the record books [for a name]," Manley said. Meanwhile, Jeep also confirmed that the Wagoneer and Grand Wagoneer models will return to its lineup in 2020, slotting above the Grand Cherokee and giving Jeep an entry in the upper luxury SUV segment. Manley said the Wagoneers will compete in the $60,000-to-$100,000 price range. They will be based on a body-on-frame platform sourced from the Ram and built in Warren, MI. "Ever since I've been associated with Jeep, in my mind, they needed to come back to the portfolio," Manley said. Jeep's other spotlight vehicle, the Grand Cherokee, will get a new generation launching in 2019, Manley said. Though the current line has been on sale since 2010, Jeep has added interior updates and special variants to keep it fresh.