1929 Model A Ford 5-window Coupe Street Rod / Hot Rod on 2040-cars

Auto blog

2017-19 Ford Super Duty trucks recalled for tailgates that could open

Ford announced two separate recalls today, though neither has resulted in any known injuries. The first recall, which deals with a tailgate malfunction, affects 261,617 examples of 2017-2019 F-250, F-350, and F-450 Super Duty pickups. The second, which anticipates the possibility of a fuel leak, affects 3,893 units of 2020 Explorer and 2020 Lincoln Aviator SUVs with 3.0-liter engines. Ford says tailgates might accidentally open on some 2017-2019 Super Duty trucks because of a short circuit. If the pickups have an electric tailgate latch-release switch on the tailgate handle, water might get into the wiring. If the water hits the right spots, a short circuit could cause the switch to release the tailgate latch. In a worst-case scenario where the tailgate opens while driving, contents of the truck's bed could fall out and create a safety hazard. Dealerships will fix the problem by modifying the tailgate frame wiring harnesses with jumper pigtails and install a new tailgate handle release switch. Of the lot, 231,664 trucks are in the U.S., and 29,953 are in Canada. The Ford recall number is 19S48.  The second recall is much smaller, involving fewer than 4,000 vehicles. In certain 2020 Explorers and Aviators with 3.0-liter engines, Ford says, "The convolute protective sleeve on the liquid fuel line is not long enough, which may allow for potential hard contact with the convolute-protected vapor fuel line. Over time, with vibration and engine roll, hard contact between the two fuel lines could cause the convolute on the vapor fuel line to rub through the plastic liquid fuel line." If that happens, it could be a fire risk and hazardous for drivers and passengers. Only 35 of those SUVs are in Canada, and the rest are in the United States. Dealers will fix the problem by replacing the defective convolute with a full-length piece and tying it down with a strap. The recall reference number for the Aviators and Explorers is 19S49. The recall adds to what has otherwise been a rocky early production phase for the new Explorers and Aviators.

Ford, Stellantis workers join those at GM in ratifying contract that ended UAW strikes

DETROIT — The United Auto Workers union overwhelmingly ratified new contracts with Ford and Stellantis, that along with a similar deal with General Motors will raise pay across the industry, force automakers to absorb higher costs and help reshape the auto business as it shifts away from gasoline-fueled vehicles. Workers at Stellantis, the maker of Jeep, Dodge and Ram vehicles, voted 68.8% in favor of the deal. Their approval brought to a close a contentious labor dispute that included name-calling and a series of punishing strikes that imposed high costs on the companies and led to significant gains in pay and benefits for UAW workers. The deal at Stellantis passed by a roughly 10,000 vote margin, with ballot counts ending Saturday afternoon. Workers at Ford voted 69.3% in favor of the pact, which passed with nearly a 15,000-vote margin in balloting that ended early Saturday. Earlier this week, GM workers narrowly approved a similar contract. The agreements, which run through April 2028, will end contentious talks that began last summer and led to six-week-long strikes at all three automakers. Shawn Fain, the pugnacious new UAW leader, had branded the companies enemies of the UAW who were led by overpaid CEOs, declaring the days of union cooperation with the automakers were over. After summerlong negotiations failed to produce a deal, Fain kicked off strikes on Sept. 15 at one assembly plant at each company. The union later extended the strike to parts warehouses and other factories to try to intensify pressure on the automakers until tentative agreements were reached late in October. The new contract agreements were widely seen as a victory for the UAW. The companies agreed to dramatically raise pay for top-scale assembly plant workers, with increases and cost-of-living adjustments that would translate into 33% wage gains. Top assembly plant workers are to receive immediate 11% raises and will earn roughly $42 an hour when the contracts expire in April of 2028. Under the agreements, the automakers also ended many of the multiple tiers of wages they had used to pay different workers. They also agreed in principle to bring new electric-vehicle battery plants into the national union contract. This provision will give the UAW an opportunity to unionize the EV battery plants plants, which will represent a rising share of industry jobs in the years ahead.

Recharge Wrap-up: Nissan earns Energy Star award, ethanol production forecasts adjusted

The US Energy Information Administration has adjusted its ethanol production forecasts. It predicts an average of 944,000 barrels per day for 2015. That number is up from 2014 production levels of 935,000 barrels per day, but it is lower than last month's projection for 2015, which was 947,000 barrels per day. The EIA forecasts 937,000 barrels per day in 2016, down from its prior forecast of 942,000 barrels. Biodiesel production averaged 83,000 barrels per day last year, with projections of 82,000 for 2015, and 84,000 for 2016. Read more from Ethanol Producer Magazine. Boston Mayor Martin J. Walsh supports the proposed Diesel and Vehicular Emissions Ordinance. The ordinance, filed by City Councilor Stephen Murphy, would require emissions control retrofitting of all pre-2007 vehicles belonging to the City of Boston, as well as those of any contractors it hires. The ordinance also seeks to create a simple city-level standard of enforcing the state's anti-idling laws. "The asthma rate in Boston's neighborhoods continues to climb," says Councilor Murphy. "By further tightening air quality standards, as this ordinance does, we will make Boston's neighborhoods healthier." Read more at DieselNet. The Michigan Blue Economy report profiles Ford for its water-saving sustainability efforts. The report notes that Ford reduced its water use by 61 percent, or 10 billion gallons, from 2000 to 2013 by "cutting the water used in everything from cooling towers to paint operations." As part of its Global Water Management Initiative, Ford has decreased its total water use at its facilities worldwide from 64 million cubic meters per year to 25 million cubic meters. Read more from Ford, or at the Michigan Blue Economy website. The EPA has named Nissan an Energy Star Partner of the Year for the fourth year in a row. The automaker received the Sustained Excellence Award for its efforts to reduce energy use and greenhouse gas emissions in its operations. Nissan reduced the amount of energy used to build vehicles by 13 percent in 2014. Energy reduction efforts include switching to LED lighting and developing an environmentally friendly paint process. Nissan also works with schools in Tennessee and Mississippi to help them reduce energy usage. "Since this initiative began in 2012, we've helped about 30 schools make the esteemed Energy Star certification list," says Nissan's John Martin. Read more in the press release below.