1998 Ford E-150 Econoline Club Wagon Custom Standard Passenger Van 2-door 5.4l on 2040-cars

Auto blog

NHTSA closes rollaway investigation into 1.56M Ford SUVs

It's taken four years of study, but the National Highway Traffic Safety Administration has finally closed the books on its investigation into rollaway accusations surrounding 1.56-million Ford SUV models.
The probe, which centered on the 2002-2005 Ford Explorer, 2002-2005 Mercury Mountaineer and 2003-2005 Lincoln Aviator, ends without the federal agency calling for a recall. According to The Detroit News, the investigation was closed due to a "low number of complaints" - NHTSA documented 180 such complaints that resulted in 14 crashes and six minor injuries, but the number of incidents have been slowing. The suspected defect rate for the trucks' automatic transmissions was found to be 4.4 per 100,000 units, and the brake-shift interlock mechanism failure rate was judged to be even lower at 3.4 per 100k.

Ford recalls 90,736 vehicles due to engine valve issue

Ford will recall 90,736 vehicles as engine intake valves in the vehicles may break while driving, the National Highway Traffic Safety Administration (NHTSA) said on Saturday. The recall impacts certain 2021-2022 Bronco, F-150, Edge, Explorer, Lincoln Nautilus, and Lincoln Aviator vehicles equipped with either a 2.7L or 3.0L Nano EcoBoost engine, the NHTSA said. According to documents posted by NHTSA and sourced from the automaker, "The engine intake valves may break while driving, which can result in engine failure and a loss of drive power." Following an investigation that started in January, 2022, Ford found 22 instances where "the engine intake valves fractured and fell into the combustion chamber of the engine causing catastrophic engine damage." The automaker's analysis continues: "Ford identified that the potential root cause of the failures was engine intake valve failure due to valves that exceeded the designed specification for hardness, were brittle, and more likely to fracture. Ford determined that this was due to the supplier’s grinding processes and the sensitivity of the intake valve material to grinding processes that were not within control specifications. The intake valve material was changed for vehicles produced after October 31, 2021." Fixing the problem will require replacement of the entire engine. "Dealers will inspect each vehicle to determine its cumulative number of engine cycles. For vehicles that do not meet the engine cycle threshold, dealers will accumulate high revolutions per minute (rpm) engine cycles per a service procedure. Engines will be replaced on vehicles that do not pass the engine cycle accumulation," Ford says.

2014 Ford F-150 Tremor adds some sport to shake things up

Like most quakes, the 2014 Ford F-150 Tremor caught us by surprise. We weren't expecting Ford to offer up another version of its best-seller so soon before the truck's full redesign, but that's exactly what the company is doing.
While Ford calls the Tremor a "performance truck," the new pickup doesn't play on the same level as the SVT Raptor does on dirt, or even the long-gone SVT Lightning did on pavement. Think of it as a parts bin sport truck that probably does a better job looking the part than acting it. The Tremor utilizes the same twin-turbo, 3.5-liter EcoBoost V6 available across the F-150 lineup, producing 365 horsepower and 420 pound-feet of torque, but matches it with a 4.10 rear axle - the shortest final drive ratio you can get in an F-150 - for the strongest possible acceleration.
The Tremor does do a decent job looking the part. Available only in short-wheelbase, regular cab configuration with your choice of two- or four-wheel drive, it struts around wearing the F-150's FX Appearance Package, flat black accents, 20-inch black wheels, HID headlights and a special exterior graphics package. The Tremor is the only regular cab F-150 with a flow-through center console, which means it also gets a floor-mounted shifter and bucket seats that are covered in black leather with red piping. Some brushed metal accents and steering wheel with red stitching round out the interior upgrades.