14 E350 15 Passenger Van Ext Xlt Privacy Glass Econoline Wagon on 2040-cars

Auto blog

Long winter means most automakers won't curb summer shutdown

A lot more happened during this latest brutal winter than days of snow and Netflix binges. Automotive sales took a battering. After all, going out car shopping when it's eleventy-billion degrees below zero isn't a good time.
Because of this Old Man Winter-induced sales slump, inventories are abnormally high as we head into the summer car buying season. That's led some analysts to predict that automakers will be more inclined to idle factories this summer, in a bid to trim some of the built-up inventory. Traditionally, American manufacturers offer up a two-week break in the middle of summer, although the burgeoning sales of the past few years have seen this practice become less popular.
"We're likely not going to see an acceleration this year," Jeff Schuster, a senior vice president at LMC Automotive, told The Detroit News. "We'll see production increases in 'pockets' but I don't know if it will be as widespread as in recent years."

Ford recalls 90,736 vehicles due to engine valve issue

Ford will recall 90,736 vehicles as engine intake valves in the vehicles may break while driving, the National Highway Traffic Safety Administration (NHTSA) said on Saturday. The recall impacts certain 2021-2022 Bronco, F-150, Edge, Explorer, Lincoln Nautilus, and Lincoln Aviator vehicles equipped with either a 2.7L or 3.0L Nano EcoBoost engine, the NHTSA said. According to documents posted by NHTSA and sourced from the automaker, "The engine intake valves may break while driving, which can result in engine failure and a loss of drive power." Following an investigation that started in January, 2022, Ford found 22 instances where "the engine intake valves fractured and fell into the combustion chamber of the engine causing catastrophic engine damage." The automaker's analysis continues: "Ford identified that the potential root cause of the failures was engine intake valve failure due to valves that exceeded the designed specification for hardness, were brittle, and more likely to fracture. Ford determined that this was due to the supplier’s grinding processes and the sensitivity of the intake valve material to grinding processes that were not within control specifications. The intake valve material was changed for vehicles produced after October 31, 2021." Fixing the problem will require replacement of the entire engine. "Dealers will inspect each vehicle to determine its cumulative number of engine cycles. For vehicles that do not meet the engine cycle threshold, dealers will accumulate high revolutions per minute (rpm) engine cycles per a service procedure. Engines will be replaced on vehicles that do not pass the engine cycle accumulation," Ford says.

Automakers drop support for Trump effort against California emissions

WASHINGTON — Toyota, Fiat Chrysler (now known as Stellantis following its merger with Peugeot) and other major automakers said on Tuesday they were joining General Motors in abandoning support for former President Donald Trump's effort to bar California from setting its own zero emission vehicle rules. The automakers, which also included Hyundai, Kia, Mitsubishi, Mazda and Subaru, said in a joint statement they were withdrawing from an ongoing legal challenge to California's emission-setting powers, "in a gesture of good faith and to find a constructive path forward" with President Joe Biden. The automakers, along with the National Automobile Dealers Association, said they were aligned "with the Biden administrationÂ’s goals to achieve year-over-year improvements in fuel economy standards." Nissan in December withdrew from the challenge after GM's decision in November shocked the industry and won praise from Biden. On Monday, the Justice Department asked the U.S. Appeals Court for the District of Columbia to put the California emissions litigation on hold to "ensure due respect for the prerogative of the executive branch to reconsider the policy decisions of a prior administration." Biden has directed agencies to quickly reconsider TrumpÂ’s 2019 decision to revoke CaliforniaÂ’s authority to set its own auto tailpipe emissions standards and require rising numbers of zero-emission vehicles, as well as Trump's national fuel economy rollback. Asked to respond to the automakers' action, White House climate adviser Gina McCarthy said in a statement that "after four years of putting us in reverse, it is time to restart and build a sustainable future, grow domestic manufacturing, and deliver clean cars for America." California Governor Gavin Newsom praised the automakers on Twitter for "dropping your climate-denying, air-polluting, Trump-era lawsuit against CA" and urged them to join the voluntary framework. TALKS WITH BIDEN Separately, an industry trade group on Tuesday proposed to start talks with Biden on revised fuel economy standards that would be higher than Trump-era standards but lower than ones set during the prior Democratic administration. The Trump administration in March finalized a rollback of U.S. Corporate Average Fuel Economy standards to require 1.5% annual increases in efficiency through 2026, well below the 5% yearly boosts under the Obama administration rules it discarded.