2014 Chevrolet Silverado 1500 Lt on 2040-cars

Auto blog

How GM engineers are using diaper 'snow' to keep you warm

Testing how snow affects General Motors' vehicles isn't really a problem right now for the company's engineers, but in the dog days of summer the process isn't exactly easy. The only real option is for them to book time at the automaker's climatic wind tunnel. However, a flash of brilliance from an engineer allows snow to be simulated regardless of the temperature outside, and the discovery is all because of his daughter's wet diaper. The realization came to GM Thermal Systems engineer Nicholas Jahn while he was swimming with his daughter and noticed how her diaper ballooned in size in the water. He found out the substance that makes this possible is called sodium polyacrylate. When the material gets wet it grows and forms fluffy flakes that are a close imitation of snow. Best of all, the stuff can be prepared easily any time of the year, and it's reusable. The engineering team uses the material to test the effectiveness of the heating systems of GM's vehicles. They spread the sodium polyacrylate over the inlets at the base of the windshield to obstruct the airflow and then crank the heater. After some time, they can see how much is being sucked into the system and design more efficient systems in the future. See how the process works in the video above and read about the diaper discovery in GM's press release below. Diapers Change Chevy Cruze Winter Warm-up Time GM validation engineer uses diaper material "snow" to reduce frigid drives 2015-01-06 DETROIT – An item commonly found on an infant's changing table is helping General Motors' engineers simulate snow year round, ensuring heating systems in cars like the 2015 Chevrolet Cruze can quickly and efficiently warm its interior. Packed snow can prevent air from entering the inlet panel at the bottom of the windshield, obstructing the flow of air into the heating system and reducing the amount of air it can push out. This can lead to less efficient warming of the car's interior and windshield defrosting. "The last thing anyone wants to do when it's freezing cold out is scrape their windshield," said Nicholas Jahn, GM Vehicle Thermal Systems engineer. "The testing we perform on the Chevrolet Cruze with the diaper material allows us to maximize the car's heating capabilities." Ironically, Jahn stumbled upon his diaper-based testing method in the middle of summer. During a swim with his daughter, he noticed her diaper multiplied in size when it came into contact with water.

It's possible to go 111 miles on electricity in the new Chevy Volt

Wayne Gerdes at CleanMPG put the 2016 Chevrolet Volt in Premiere trim through a few closely watched on-the-road tests over a few days. One of them was a run from full charge to EV-only exhaustion, and at the end of the trip Gerdes had traveled 111.0 indicated miles on a single charge, 111.9 according to his Garmin. What's the catch? He guessed his average speed was about 20 miles per hour, which was 15 and 20 mph around town and "a few miles" at 50 mph on the highway. The EPA says the new Volt should go 53 miles on battery power. In the 2011 Volt, rated at 38 electric miles, Gerdes got 75.5 miles on a charge. The upshot is that at urban driving at average speeds should get drivers the EPA rated 53 e-mpg without fuss. He wasn't so impressed with performance in Charge Sustaining Mode, though. During one run that covered 101.2 actual miles in CSM, using 1.691 gallons, the Volt got 59.8 mpg. Speaking of driving in CSM only, Gerdes said it's less efficient here than in competitors from Toyota, Honda, and Hyundai, but that's one of the few performance-related complaints he had. Elsewhere around the PHEV, Gerdes liked improvements to the eight-inch display and rear-view camera, build and design quality, the much quieter ride, and the switch to regular fuel. The six-foot Gerdes found the cabin space still cozy, especially in the back where ingress and egress could be a challenge for people of a certain stature. He lamented the fact that he couldn't find instantaneous fuel and energy consumption or among the many readouts, and would prefer the sedan kicked into glide mode sooner. In spite of that, he declares the Volt II "a full blown electric car." Head over to CleanMPG for the rest of his assessment.

NHTSA approves hybrid rearview mirror display in Cadillac CT6, Bolt EV

The Chevy Bolt EV prototype doesn't just have a fancy new all-electric powertrain. Just outside the driver's line of sight is a newfangled rearview mirror, one that can turn into a screen that shows a moving image from the rear-facing camera. Speaking to NPR's Robert Siegel yesterday, Department of Transportation secretary Anthony Foxx said that NHTSA has now approved this type of mirror/screen for use in vehicles. According to a letter from NHTSA to General Motors, GM will likely use this Full Display Mirror first in the 2016 Cadillac CT6 before coming to the Bolt. In its letter to GM, NHTSA said that the Full Display Mirror will only qualify as a standard rearview mirror as long as there are normal side mirrors in place. In other words, don't expect to see cameras and screens replacing all the mirrors in a motor vehicle just yet. @AutoblogGreen @NPR - #NHTSA has OK'd GM rear-view system that can switch between mirror & camera views. pic.twitter.com/6CBeIit10v — Anthony Foxx (@SecretaryFoxx) February 22, 2016 The Full Display Mirror was developed by Gentex, which has long worked with GM. The FDM debuted in 2014 and some people hoped it would also make its way into the Tesla Model X. Gentex, which also makes auto-dimming mirrors, says that it has "set out to develop the technologies and core competencies necessary to manage this evolution of the rearview mirror." The Chevy Bolt EV will start at $37,500, before incentives. The 200-mile EV will go into production late this year for likely sale in early 2017. Related Video: