1969 Volkswagen Beetle Convertible on 2040-cars

Auto blog

An inside look at VW's new California R&D center

Less than two months ago, the Volkswagen Group opened a new facility in Oxnard, California (about an hour's drive west of Los Angeles). The $27 million investment, touted as Test Center California (TCC), serves as a research and development lab testing emissions for all brands under Volkswagen's umbrella, including its newest member, Porsche. While still not fully operational, we toured the new 64,000-square-foot building last week and had a first-hand opportunity to see just how much work is involved testing engines and meeting increasingly stringent government emissions standards.
Replacing a similar facility established in 1990 in Westlake Village (about 20-minutes east of the new location), our guide explained how Oxnard was chosen for its temperate climate, varied regional terrain for test drives and low altitude. (The area is only a few feet above sea level - a critical parameter when instrument testing emissions.) The new facility is capable of analyzing hundreds of vehicles, prototypes and customer-owned vehicles, annually.
Most interesting to us was the huge stainless steel climate chamber, with a massive four-wheel dynamometer that allows VW to test running vehicles in both scorching desert and freezing climates without ever leaving the building (an Audi Q7 was running in place during our visit). We were also mesmerized by the countless storage tanks and intricate plumbing of chemicals, stored in both liquid and gas states, needed to perform the variety of tests. Lastly, we took a look at Bugatti's service center on the west coast, located completely within the new center. While there were no supercars on site, the facility is equipped with plenty of spare forged wheels (mounted with expensive Michelin PAX tires) and a Veyron-specific repair jig that allows the vehicle to be completely disassembled, if needed. It is a shame that the facility, which set off all of our automotive geek alerts, is closed to the public.

Volkswagen Cross Up! aimed at rugged lifestyle folks, complete with plastic cladding

If you thought there was nothing wrong with the Volkswagen Up! that a little body cladding wouldn't fix, you're in luck. VW has officially pulled the wraps off the production version of the Cross Up!, and its wheel arches and rocker panels are full of the black plastic cladding you've been yearning for.
In addition to the "particularly rugged design and tough, lifestyle qualities" that the cladding exudes, VeeDub has also seen fit to put its Cross Up! on a new set of 16-inch alloy wheels clad in 185/50-series tires. Inside, there are new kick plates to go along with a dash pad that can be had in red, black or silver.
All that cladding must equal additional off-road readiness, right? Well, sure... just so long as you're fine with the same 75-horsepower three-cylinder engine that all other Up! models also feature, along with a five-speed manual transmission sending power to the front wheels, again, just like all other Up! models. The Cross Up! appears to have a taller ride height than other models, but we haven't been able to find out what - if any - changes have been made.

Volkswagen Golf Wagon caught completely uncovered

Without a lot of information to go with them, our camera-toting spies have captured some new images of a Volkswagen Golf wagon variant that is almost completely undisguised. In fact, the one piece of camouflage on the tidy wagon would probably have gone unnoticed to most casual viewers. Look closely at the rear three-quarter view of the car and you'll notice that the apparent taillight clusters are actually fakes - the outline of the real units is faintly visible behind the blue bodywork and the sticker-like fake taillights.
It's a good guess then, that this Golf wagon (called a Golf Kombi by our spy photographer) is a prototype that's pretty far along in the development cycle for Volkswagen. We can't be sure what impact this will have on the company's small wagon offering here in the US, but we'd be pretty surprised if something very like this didn't end up as the next Jetta SportWagen. We might well have more information on that front, after we visit Geneva next week.