1987 Suzuky Samurai on 2040-cars

Auto blog

205k Suzuki models being investigated for airbag sensor issue

The Detroit News is reporting that the National Highway Traffic Safety Administration has opened an investigation on the 2006-11 Suzuki Grand Vitara and 2007-11 Suzuki SX4 due to issues with the airbag and seatbelt for the front passenger seat. So far, NHTSA has received 128 complaints on these vehicles for airbag warning lights, airbag off lights and seatbelt lights, on a vehicle set that totals around 205,000 units, but there is no indication as to how many, if any, injuries have reported.
Via technical service bulletins, Suzuki has already acknowledged two airbag-related issues with front passenger seats on both vehicles, including a programming error for the passenger seat load indicator on 2009 models and an open-circuit problem for the sensor mat that determines if an adult or child is sitting in the front seat. Since this latter issue would not shut off or lessen the impact of the passenger airbag, Suzuki has already extended the warranty for the seat cushion bottom to 10 years or 120,000 miles. After ceasing new-car sales in the US and Canada, potential recall repairs (which still may or may not happen) would be handled by remaining dealers as laid out in the recent court-approved bankruptcy plan.

Suzuki reopens India plant post-riot with police outnumbering workers

Suzuki's plant in Manesar, India builds cars for Australia, specifically its Alto small car. Or at least they were building cars before violent worker riots forced the factory to close. The plant has been idled for five weeks as a result of worker violence that led to the death of one manager and 95 injuries. The riot was spurred over a labor dispute - specifically, a gulf in salaries between temporary workers and their salaried counterparts who earn triple the contract workers' wages.
According to reports, on Tuesday, the factory re-opened with more than 1,200 police officers stationed around the plant. The staff of actual workers at the plant numbers just 75 currently, meaning the police force greatly outnumbers Suzuki employees.
The number of employees will eventually grow to 300, and the officers will run in shifts of 100 at a time, but the initial disparity of workers to police is meant as a show of force to the more than 500 permanent and 500 temporary workers who were found to be involved in a July 18 riot.

Suzuki calls in 26,000 Daewoo-built Veronas for overheating lights

Suzuki is recalling yet another Daewoo-built model due to possible problems with the daytime running light module in the instrument panel. This time it covers about 25,899 units of the Suzuki Verona from the 2004 through 2006 model years that need fixing. Like the repair campaign of the Forenza and Reno in May, it's possible for the part to overheat, melt and potentially cause a fire.
According to the Chronology of Principal Events section in the defect notice submitted to the National Highway Traffic Safety Administration, this recall was actually a direct result of the Forenza/Reno campaign. After finding the problem in those vehicles, General Motors Korea started investigating for more affected models and discovered that the Verona was also at risk. However, the report says that no cases of melting or fires have been found in the Verona.
Obviously, Suzuki will be notifying affected owners and will replace the DRL module free of charge. Scroll down to read the recall request or check out the full defect notice in PDF format, here.