2004 Jeep Grand Cherokee Laredo Sport Utility 4-door 4.7l on 2040-cars

Auto blog

Jeep idles second shift it hired a month ago for 2014 Cherokee

In an unusual move, Chrysler is idling its recently hired second shift of 2014 Jeep Cherokee builders because, Chrysler spokeswoman Jodi Tinson said in a statement, it already has built the "critical number of vehicles we need to stock dealerships once containment is released," Automotive News reports.
After the "critical" 9,430 Cherokees were built, the layoff was enacted so as not to strain the automaker's logistics partners before the Cherokee is actually released. Chrysler says the temporary layoff will last about two weeks, with 500 workers out of work and another 600 reassigned at the Toledo Assembly Complex where the sports utility vehicle was being built. The second-shift workers were hired on August 19.
Chrysler previously insisted that it would release the Cherokee to dealerships by the end of the third quarter, and it initially planned to start selling the SUVs in mid-August. Apparently the Cherokee needed a software fix before hitting showrooms, which is how Chrysler explains why the release schedule is out of whack. We're thinking that this software fix addresses the "powertrain calibration" issue that delayed the first media test drives of the model. According to the Toledo Blade, Chrysler has admitted it is doing "extended quality validation testing" but refused to provide more information.

Chrysler recalls 468,700 Jeep Grand Cherokees, Commanders over rollaway risk

Chrysler has issued a recall covering a combined 469,000 units of the 2005-2010 Jeep Grand Cherokee and the 2006-2010 Jeep Commander (inset). Of that number, 295,000 are in the US, roughly 33,000 in Canada and Mexico and the remainder in other markets. It seems an electrical fault in the transfer case can allow the affected SUVs to shift into neutral on their own, while an Associated Press report says that Chrysler had "found cracks in a circuit board that turns the four-wheel-drive system on and off." The issue was discovered when an owner started his car remotely and it rolled away.
Chrysler is expected to begin notifying owners in June 2013, who can then take their cars to dealers. The dealer will reflash the final drive controller free of charge. There's a bulletin from the National Highway Traffic Safety Administration below with more information.

What's really going on with the 2014 Jeep Cherokee's transmission issues?

On September 23, Automotive News reported that Chrysler had idled the second shift workers it hired just five weeks prior at its Toledo Assembly Complex to build the 2014 Jeep Cherokee. At the time, Chrysler said it had "built the critical number of vehicles we need to stock dealerships once containment is released" and did not want "to put additional strain on our logistics partners ... upon release." That reasoning was not only unusual, it didn't seem to make sense.
It appears the center of the nine-speed issue is software, not hardware.
That same day, the Detroit News ran a piece claiming workers at the Toledo factory said the halt was due to issues with the Cherokee's transmission. It put the number of already-built Cherokees needing fixes at 1,000 and said that some of the workers not laid off had been instructed "to take the Jeep on long test-drives." That made more sense. Three days later, on September 26, Automotive News reported that the 500 workers laid off had been reinstated, with engineers "speeding repairs on the SUV's powertrain software." The AN piece didn't put a number on how many units are being fixed, but it did say that 12,000 have been built and are awaiting delivery to dealers. The best it could say about when dealers will get them, however, is that "progress on a fix is being made. It's unclear when shipments to dealers will start."