1996 Jeep Grand Cherokee Laredo 4x4 Zj on 2040-cars

Auto blog

Chrysler recalls 468,700 Jeep Grand Cherokees, Commanders over rollaway risk

Chrysler has issued a recall covering a combined 469,000 units of the 2005-2010 Jeep Grand Cherokee and the 2006-2010 Jeep Commander (inset). Of that number, 295,000 are in the US, roughly 33,000 in Canada and Mexico and the remainder in other markets. It seems an electrical fault in the transfer case can allow the affected SUVs to shift into neutral on their own, while an Associated Press report says that Chrysler had "found cracks in a circuit board that turns the four-wheel-drive system on and off." The issue was discovered when an owner started his car remotely and it rolled away.
Chrysler is expected to begin notifying owners in June 2013, who can then take their cars to dealers. The dealer will reflash the final drive controller free of charge. There's a bulletin from the National Highway Traffic Safety Administration below with more information.

Jeep gunning to build 250,000 Cherokees a year

Contrary to what a certain politician may have said last year about Jeep moving to China, the automaker is in fact doing the opposite, with plans to greatly increase the production capacity at its Toledo North Assembly plant in Ohio. The Detroit Free Press is reporting that there are big plans for the 2014 Jeep Cherokee and Toledo North, as a local union president has informed the newspaper that Chrysler is planning to produce around 250,000 examples of the new midsize utility per year.
To put this number into context, 250,000 units is more than what Jeep Liberty sales totaled here over the last three years combined. Even taking into consideration that the 250,000 units will be distributed beyond US borders, that's an ambitious volume figure full-stop - and that's without taking into consideration the new Cherokee's love/hate design. In its favor, though, Jeep is making remarkable inroads globally as of late, and the Cherokee's size could work well in emerging markets. To get that kind of output from Toledo's Cherokee assembly line, Chrysler will reportedly hire 1,105 new workers - that's in addition to the 200 workers already being hired to build the popular Jeep Wrangler, which is itself expected to top 220,000 units this year.

7 months later, Jeep 'trailer hitch' recall still stalled

For the past few years, Chrysler and its CEO, Sergio Marchionne, have gone head-to-head with the National Highway Traffic Safety Administration and its boss, David Strickland, over the government safety agency's request for Chrysler to recall almost three-million Jeep vehicles due to what NHTSA says is a safety issue that has caused at least 51 deaths. After a three-year investigation and Chrysler's initial refusal to issue a recall because it deemed the vehicles safe and built to the day's federal requirements, last summer, the two parties compromised on a "voluntary campaign" to inspect 1.56 million vehicles, those being the 1992 to 1998 Grand Cherokee and 2002 to 2007 Liberty.
Those vehicles were designed with their gas tanks between the rear axle and the bumper, and NHTSA says that in rear-end collisions, damage to the fuel tank has caused fires responsible for those 51 deaths. The compromise reached last summer was that Chrysler would inspect 1.56 million vehicles and, "if necessary, provide an upgrade to the rear structure of the vehicle." Practically speaking, that meant Chrysler would replace aftermarket trailer hitches, but would take no action if a vehicle had a factory-installed hitch or an aftermarket hitch from Mopar.
A report in The Detroit News says the "voluntary campaign" is just now getting under way, with Chrysler saying last week that the design of the replacement part had been finalized and it was tooling up "to deliver the required volume." Seven months later, still in question is whether NHTSA will crash-test the fix engineered by Chrysler, noteworthy because not only did the vehicles in question pass every safety standard necessary to be cleared for sale at the time, there are still questions (to those of us on the outside) as to how the Jeeps at issue fare among their peers in such incidents. Either way, Chrysler and NHTSA apparently still disagree on the efficacy of the remedy itself: the carmaker says it might help in low-speed crashes but not high-speed collisions, a position the NHTSA is at odds with. All of this means the campaign doesn't yet have an end in sight.