2001 Vw Passat on 2040-cars

Auto blog

An inside look at VW's new California R&D center

Less than two months ago, the Volkswagen Group opened a new facility in Oxnard, California (about an hour's drive west of Los Angeles). The $27 million investment, touted as Test Center California (TCC), serves as a research and development lab testing emissions for all brands under Volkswagen's umbrella, including its newest member, Porsche. While still not fully operational, we toured the new 64,000-square-foot building last week and had a first-hand opportunity to see just how much work is involved testing engines and meeting increasingly stringent government emissions standards.
Replacing a similar facility established in 1990 in Westlake Village (about 20-minutes east of the new location), our guide explained how Oxnard was chosen for its temperate climate, varied regional terrain for test drives and low altitude. (The area is only a few feet above sea level - a critical parameter when instrument testing emissions.) The new facility is capable of analyzing hundreds of vehicles, prototypes and customer-owned vehicles, annually.
Most interesting to us was the huge stainless steel climate chamber, with a massive four-wheel dynamometer that allows VW to test running vehicles in both scorching desert and freezing climates without ever leaving the building (an Audi Q7 was running in place during our visit). We were also mesmerized by the countless storage tanks and intricate plumbing of chemicals, stored in both liquid and gas states, needed to perform the variety of tests. Lastly, we took a look at Bugatti's service center on the west coast, located completely within the new center. While there were no supercars on site, the facility is equipped with plenty of spare forged wheels (mounted with expensive Michelin PAX tires) and a Veyron-specific repair jig that allows the vehicle to be completely disassembled, if needed. It is a shame that the facility, which set off all of our automotive geek alerts, is closed to the public.

Volkswagen says goodbye to Eos, Routan in 2015 updates

Usually automakers announce changes to their lineup individually on a vehicle-by-vehicle basis, but sometimes it all comes at once - especially when the changes are ones we either expected or might not otherwise notice. That's the path Volkswagen has gone with changes to its US lineup for 2015.
The biggest change is what we already knew: that the new Golf arrives for the 2015 model year, bringing with it the new GTI, Golf R, e-Golf and Golf SportWagen (to replace the previous Jetta wagon). But there are some new details as well.
For starters, Volkswagen has finally confirmed that both the Eos and the Routan - both long rumored to be on their way out - will be exiting this year. The Eos hardtop convertible, pictured above, will linger for one last year, its Sport trim replaced by a new Final Edition with 18-inch wheels, two-tone leather interior and enhanced equipment.

CARB has 20 days to confirm VW's 3.0-liter TDI emission fix

VW's diesel scandal has been in the headlines since last September, but solving the problem it proving difficult. Volkswagen Group has submitted a proposal to the California Air Resources Board (CARB) and the Environmental Protection Agency (EPA) to fix about 85,000 vehicles with the 3.0-liter diesel V6 in the US, Reuters reports. CARB now has 20 business days to test if the plan actually reduces emissions. If accepted, VW could finally begin a recall and end the stop sale on vehicles with these engines. In a statement, CARB pledged to, "respond following a thorough and complete review to make sure the plan addresses the presence of the illegal defeat device and follows the necessary environmental, vehicle and public health and safety regulations." Neither CARB nor the EPA outlined the proposed repairs, but Porsche CEO Oliver Blume already suggested the fix for the engine in the diesel Cayenne. Examples from 2013 and 2014 allegedly need a new catalytic converter and software update, and those from 2015 and 2016 only need the improved code. It's not yet clear whether this procedure would work for all models with the 3.0 TDI. While the EPA issued the notice of violation against VW's 2.0-liter four-cylinder diesel in September, the first one for the 3.0-liter V6 came in early November. By the end of the month, the agency broadened the scope to about 85,000 vehicles, including some examples of the VW Touareg, Audi A6, A7, A8, Q5, Q7, and Porsche Cayenne. The affected companies issued stop sales on new models with the engine. Audi eventually admitted to regulators that it didn't disclose three auxiliary emission control devices in the powerplant's code and promised to develop a software update to fix the problem. CARB gave the automaker 45 business days to submit the proposed solution. If accepted, this repair would allow VW Group to end part of the emissions scandal, but there's no guarantee the regulators consent to this solution. Just a few weeks ago, CARB looked at the automaker's plan to fix the 2.0-liter TDI and rejected it, claiming a lack of detail.