2003 Gti 20 Th Aniversary 6 Speed Manual 98k Miles on 2040-cars

Auto blog

VW Jetta TDI dyno shows HP loss trying to recreate cheat mode

Volkswagen is working on a fix for diesel-engined vehicles that are out of compliance with emissions regulations in the US and other countries. We're told that engineers will be presenting a solution internally sometime this month, but that doesn't mean we'll actually see it in the wild this month. One big question we have about the coming fix is, will it affect the car's performance? That question relates to another we have about the engine as it is: How much performance would the 2.0-liter diesel lose right now if it were turned down to pass US emissions? The Fast Lane Car tried to sketch some answers by going to a shop in Denver, Colorado to run a 2011 Jetta TDI with a six-speed DSG transmission on an all-wheel-drive dyno. The thinking was that if you ran all four wheels the car would think it was on the road, whereas if you ran only two the car might think it's being tested. We'll get straight to the numbers: the stock sedan is quoted at 140 horsepower and 236 pound-feet of torque. When run with all four wheels turning it produced an uncorrected 114 hp and 214 lb-ft at the wheels. When run with just two wheels in motion the Jetta got 113 hp and 188 lb-ft at the wheels. Reading the graph, we're told that power differences between the two runs were as much as 15 hp and 32 lb-ft. You'll need to take some salt with these numbers, though, because the dyno and test protocol in the video are nothing like those used by the EPA. The shop attempts to trick the Jetta into 'emissions testing mode' by using the front wheels only for the two-wheel-drive run, but we have a feeling the software code at issue is far more sophisticated than that, since the ICCT, UVA, the EPA, and CARB investigated the situation for more than a year and couldn't figure out. Also, the technician adjusts for being a mile above sea level with a correction factor of 1.2 applied to horsepower and torque, which inflates the disparity in the final power differences over the two runs. Go to YouTube and read the lengthy comments on the video left by Andrew Price for a more thorough dissection of what could explain TFL's disparities. You can watch the video above, and feel free to try and dissect the results yourselves in the comments below. Related Video:

An inside look at VW's new California R&D center

Less than two months ago, the Volkswagen Group opened a new facility in Oxnard, California (about an hour's drive west of Los Angeles). The $27 million investment, touted as Test Center California (TCC), serves as a research and development lab testing emissions for all brands under Volkswagen's umbrella, including its newest member, Porsche. While still not fully operational, we toured the new 64,000-square-foot building last week and had a first-hand opportunity to see just how much work is involved testing engines and meeting increasingly stringent government emissions standards.
Replacing a similar facility established in 1990 in Westlake Village (about 20-minutes east of the new location), our guide explained how Oxnard was chosen for its temperate climate, varied regional terrain for test drives and low altitude. (The area is only a few feet above sea level - a critical parameter when instrument testing emissions.) The new facility is capable of analyzing hundreds of vehicles, prototypes and customer-owned vehicles, annually.
Most interesting to us was the huge stainless steel climate chamber, with a massive four-wheel dynamometer that allows VW to test running vehicles in both scorching desert and freezing climates without ever leaving the building (an Audi Q7 was running in place during our visit). We were also mesmerized by the countless storage tanks and intricate plumbing of chemicals, stored in both liquid and gas states, needed to perform the variety of tests. Lastly, we took a look at Bugatti's service center on the west coast, located completely within the new center. While there were no supercars on site, the facility is equipped with plenty of spare forged wheels (mounted with expensive Michelin PAX tires) and a Veyron-specific repair jig that allows the vehicle to be completely disassembled, if needed. It is a shame that the facility, which set off all of our automotive geek alerts, is closed to the public.

Volkswagen Golf R Evo may debut at Beijing Motor Show

If a report in Auto Express is correct, a lighter, faster brother to the Volkswagen Golf R will be shown to the world at the Beijing Motor Show in April. Said to be called the Golf R Evo, the even harder hot hatch would be unveiled as one of those concepts that's practically a de facto presentation of the genuine thing. The Evo in its name will come from having a carbon fiber roof and CF in the bodywork, lighter wheels, thinner bucket seats up front and a roll cage instead of rear seats.
If there's a power increase, it's been described as "a small bump." However, as the report mentions, if the Jenny Craig regimen can drop 100 kilograms (220 pounds) from the the 3,247-pound weight of the European Golf R, then the Golf R Evo will do about the same damage on the scales as the Golf but have at least 50 more horsepower and 44 more pound-feet of torque.
Since we still don't have the current Golf, this isn't something that should keep you awake even if the 'concept' does become a production model. But it is good to know that the Golf R is really going to start pushing its boundaries.