So. Calif Car-rustfree-very Original-dependable-runs,drives Great! 68 69 71 72 on 2040-cars

Auto blog

Crash test videos show how rust compromises safety

These recently released Swedish videos serve as a reminder that rust isn't just a cosmetic flaw, when it comes to cars. The insurance company Folksam and the homeowner organization Villaagarnas Riksforbund gathered examples of two relatively popular, but by now rusty cars, and then performed crash tests with them at the Thatcham Research facility in Britain. The results are sobering. The rustier cars chosen for the tests were first-generation Mazda6s, cars that have a reputation for early-onset rust in salty surroundings, such as the Nordic countries in Europe or the Salt Belt in the U.S. The cars in the other end of the spectrum were fifth-generation Volkswagen Golfs, which thanks to their body treatment only really start to show rust at over ten years old. But rust isn't just on the surface, it goes bone deep. While the Mazda did decently well in Euro NCAP testing as a new car, there's now a 20 percent higher risk of death in the 2003-2008 Mazda due to the degradation of its bodyshell. In the rusty car, the chassis rail separates from the floor, the footwell ruptures, the sill gives way, the seat mountings move and the dummy's head hits the B-pillar; all important failures, despite Thatcham saying the cars actually performed better in the crashes than they expected with all the rust. But still, the corroded structure isn't able to transmit loads in the way it was originally designed to do. This content is hosted by a third party. To view it, please update your privacy preferences. Manage Settings. The Golf does significantly better — despite rust flakes flying when the Golf hits the wall — as the years have only caused it to lose a single point. An important thing to remember is that the cars aren't tested in comparison to corresponding new, 2018 cars: the tests are in reference to the crashworthiness standards in place when they were new. The cars' airbags inflate like they were supposed to, but on the Mazda the dummy's head bottoms out the airbag due to the car's structure failing, meaning the airbag cannot perform as designed. Driven cautiously, an older car is still mostly fine for driving around. But tests like these remind us that it's not enough that a car runs and drives, if the body has turned into Swedish knackebrod. And if you repair the visible rust and the structure underneath remains as compromised as ever, there's an ugly truth under all the bondo. Perhaps it isn't such a bad idea to have yearly roadworthiness inspections.

Volkswagen's new Passat Alltrack ready to scale the Alps

Volvo may be stepping up its off-roading game with a greater variety of Cross Country models tumbling out the factory in Gothenburg, but the other (larger) European automaker whose name starts with the letters V-O-L is also broadening and updating its range of road-going automobiles equipped to handle a little soft-road duty. Aside from Audi's Allroad line, Skoda's Scout models and the new Seat Leon X-Perience, the Volkswagen brand itself has recently showcased Alltrack versions of the Golf, Multivan and of course the Passat. And now it's announced a new version of the latter for the European market. Based on the Euro-spec Passat Variant, the new VW Passat Alltrack follows a familiar formula: take a station wagon, equip it with all-wheel drive, jack up the suspension, add some lower body cladding and some new trim and – voila! – you've got a pseudo rough-roader on your hands. Set to debut in just a couple of weeks from now at the 2015 Geneva Motor Show, the new Passat Alltrack is visually distinguished by its new bumpers, underbody protection, beefed-up wheel arch moldings and a ride height increased by over an inch to the benefit of ground clearance as well as approach and departure angles. European buyers who like to leave the road every once in a while (or give the impression that they do) will be able to choose from a range of five engines: two burning gasoline with either 148 horsepower or 217, and three diesels available in 148-, 187- or 237-hp states of tune. The base TSI and TDI engines are mated to a six-speed manual, while the top three are hooked up to a six-speed DCT, but they all come with 4Motion all-wheel drive as standard. All but the base TSI model boast a towing capacity of 1,800 kg, enhanced by a Trailer Assist system that automatically lines the vehicle up to a trailer. It even comes equipped with an off-road mode that incorporates Hill Start Assist and Hill Descent Assist to make any journey across the Alps a breeze. Wolfsburg / Geneva, 19 February 2015 World premiere of the new Passat Alltrack All-wheel drive all-rounder combines the best of on-road and off-road driving - Passat Alltrack: 100 per cent 4MOTION – from 150 PS to 240 PS - Superior off-road performance with off-road mode and all-wheel drive Ten important facts about the world premiere of the Passat Alltrack: 1. Permanent 4MOTION all-wheel drive as standard. 2. Distinctive off-road look with new bumpers, underbody protection, door sill and wheel arch trims. 3.

Volkswagen planning Up! hybrid model using XL1 powertrain

Even though we've finally gotten a look at the production version of the 261-mile per gallon Volkswagen XL1, this aero-shaped two-seater was never intended for high-volume sales. Fortunately, it sounds like the same isn't true for the car's diesel plug-in hybrid powertrain, which, according to a report from AutoCar, could make its way under the hood of another Volkswagen model: the Up! minicar (shown above).
A potential Up! Hybrid would likely be able to return some of the same impressive fuel economy numbers as the XL1, but it would be a more realistic car with more passenger space and greater production capacity. The hand-built XL1 will use a 47-horsepower, two-cylinder TDI engine paired to a seven-speed dual-clutch transmission, and the 27-hp electric motor and lithium-ion battery helps deliver an all-electric driving range of 31 miles.
One of the core pillars of the XL1's design is its lightweight construction with a 1752-pound curb weight, which makes the Up! a perfect recipient for using this powertrain since it weighs just 300 pounds more. The report says that the Up! Hybrid is still in the developmental phase, so a production version isn't expected for at least another 18 months.