1973 Vw Super Beetle on 2040-cars

Auto blog

Crash test videos show how rust compromises safety

These recently released Swedish videos serve as a reminder that rust isn't just a cosmetic flaw, when it comes to cars. The insurance company Folksam and the homeowner organization Villaagarnas Riksforbund gathered examples of two relatively popular, but by now rusty cars, and then performed crash tests with them at the Thatcham Research facility in Britain. The results are sobering. The rustier cars chosen for the tests were first-generation Mazda6s, cars that have a reputation for early-onset rust in salty surroundings, such as the Nordic countries in Europe or the Salt Belt in the U.S. The cars in the other end of the spectrum were fifth-generation Volkswagen Golfs, which thanks to their body treatment only really start to show rust at over ten years old. But rust isn't just on the surface, it goes bone deep. While the Mazda did decently well in Euro NCAP testing as a new car, there's now a 20 percent higher risk of death in the 2003-2008 Mazda due to the degradation of its bodyshell. In the rusty car, the chassis rail separates from the floor, the footwell ruptures, the sill gives way, the seat mountings move and the dummy's head hits the B-pillar; all important failures, despite Thatcham saying the cars actually performed better in the crashes than they expected with all the rust. But still, the corroded structure isn't able to transmit loads in the way it was originally designed to do. This content is hosted by a third party. To view it, please update your privacy preferences. Manage Settings. The Golf does significantly better — despite rust flakes flying when the Golf hits the wall — as the years have only caused it to lose a single point. An important thing to remember is that the cars aren't tested in comparison to corresponding new, 2018 cars: the tests are in reference to the crashworthiness standards in place when they were new. The cars' airbags inflate like they were supposed to, but on the Mazda the dummy's head bottoms out the airbag due to the car's structure failing, meaning the airbag cannot perform as designed. Driven cautiously, an older car is still mostly fine for driving around. But tests like these remind us that it's not enough that a car runs and drives, if the body has turned into Swedish knackebrod. And if you repair the visible rust and the structure underneath remains as compromised as ever, there's an ugly truth under all the bondo. Perhaps it isn't such a bad idea to have yearly roadworthiness inspections.

Volkswagen Multivan Alltrack Concept takes the luxury van life off road

Volkswagen dug into its commercial vehicle fleet for its latest Geneva Motor Show concept, blending the versatile body of the T5 MultiVan with a luxuriously appointed interior, 4Motion all-wheel drive and a thrifty diesel powertrain.
That 177-horsepower diesel engine routes its power to the AWD system through a seven-speed dual-clutch transmission. Based on that alone, we'd expect the Multivan Alltrack's behind-the-wheel experience to be somewhat familiar. That all-wheel-drive system and van body contribute to the 21-degree approach and 15-degree departure angles of this soft-roading MultiVan.
What wouldn't be familiar is its exquisite cabin. Volkswagen opted for a nautical theme for the concept's interior, featuring grey-blue leather seats from Poltrona Frau and a floor finished in real wood. The dark wood trim can also be found throughout the interior, running below the windows and on the dash.

VW confirms Audi's emissions test transmission anomalies

Just a week after reports that the California Air Resources Board (CARB) found an emissions cheat in some Audi automatic transmission software programs, parent company Volkswagen has come clean. As reported by Reuters, VW's response to an article by Munich's Sueddeutsche Zeitung stated that the adaptive shift functionality can "lead to incorrect and non-reproducible results." Adaptive shift programs alter the characteristics of a vehicle's transmission to suit different driving styles. Gentle driving will result in earlier shifts and lower engine revs, while hard-charging on the pedals and steering will make the transmission more responsive and hold gears longer. That adaptation can change over time or even on a short-term basis. And it can save fuel. The difference in this case is that is seems that the Audi transmissions were specifically programmed to detect emissions test conditions. As we explained in a previous article, one of those test conditions is keeping the wheel straight. Turning more than 15 degrees shuts the test mode off. According to Reuters, the US government is trying to determine whether this classifies as an emissions cheat device, although VW, Audi, and the EPA have not commented on the record. This latest accusation is separate from the larger VW diesel emissions scandal. Related Video: Image Credit: Getty Editorial Government/Legal Green Audi Volkswagen Emissions vw diesel scandal