2002 Volkswagen Eurovan Winnebago Camper on 2040-cars

Auto blog

An inside look at VW's new California R&D center

Less than two months ago, the Volkswagen Group opened a new facility in Oxnard, California (about an hour's drive west of Los Angeles). The $27 million investment, touted as Test Center California (TCC), serves as a research and development lab testing emissions for all brands under Volkswagen's umbrella, including its newest member, Porsche. While still not fully operational, we toured the new 64,000-square-foot building last week and had a first-hand opportunity to see just how much work is involved testing engines and meeting increasingly stringent government emissions standards.
Replacing a similar facility established in 1990 in Westlake Village (about 20-minutes east of the new location), our guide explained how Oxnard was chosen for its temperate climate, varied regional terrain for test drives and low altitude. (The area is only a few feet above sea level - a critical parameter when instrument testing emissions.) The new facility is capable of analyzing hundreds of vehicles, prototypes and customer-owned vehicles, annually.
Most interesting to us was the huge stainless steel climate chamber, with a massive four-wheel dynamometer that allows VW to test running vehicles in both scorching desert and freezing climates without ever leaving the building (an Audi Q7 was running in place during our visit). We were also mesmerized by the countless storage tanks and intricate plumbing of chemicals, stored in both liquid and gas states, needed to perform the variety of tests. Lastly, we took a look at Bugatti's service center on the west coast, located completely within the new center. While there were no supercars on site, the facility is equipped with plenty of spare forged wheels (mounted with expensive Michelin PAX tires) and a Veyron-specific repair jig that allows the vehicle to be completely disassembled, if needed. It is a shame that the facility, which set off all of our automotive geek alerts, is closed to the public.

VW announces recall of 26,000 2014 models with 1.8T engines

Volkswagen has followed up on a stop-sale order from earlier this month, announcing a voluntarily recall of 26,400 vehicles that are powered by the brand's 1.8-liter, turbocharged four-cylinder engine. The new mill replaced the despised 2.5-liter five-cylinder in the Jetta, Passat, Beetle and Beetle Convertible last year. Weirdly, though, of the 26,452 units covered in the recall, only 1,655 are customer vehicles.
According to VW, the affected models were built between February 1 and April 6 of this year, and feature bad O-ring seals in the transmission oil cooler. Apparently, the faulty O-rings could cause a fluid leak, as they won't seal between the oil cooler and transmission. VW is blaming a material change from a supplier for the problem.
There have been no fires, injuries, accidents or fatalities relating to this issue, which VW will be fixing free of charge. Customers will need to report to dealers to have the O-rings replaced.

Volkswagen Golf Variant Concept R-Line puts the sport in SportWagen

With the introduction of the newest Volkswagen Golf Variant, we get an early look at what will most likely be the next-generation Jetta SportWagen here in the US. To further wet our appetities, VW is now teasing something a little sportier with the Concept R-Line. Looking the part of a GTI wagon (or a stretched Golf R), the Golf Variant Concept R-Line has a production-ready appearance that has us hoping we'll see this sporty wagon sooner rather than later.
The R-Line starts off with a new fascia that isn't quite as aggressive as the recently introduced GTI, but it gives the new styling some extra punch. Below the fascia is a lower splitter that visually carries back into the rocker panel extensions, and the rear of the car gets some bright exhaust tips and a rear diffuser. The Lapis Blue Metallic paint job probably does enough on its own to add a sporty flair to the Golf wagon, and it's all finished off with 18-inch split-spoke wheels. Inside, the Concept R-Line shows off sport seats wrapped in carbon leather featuring blue nappa inserts in the middle.
Rightfully so, VW brought the Concept R-Line to Geneva with its TDI and 4Motion all-wheel-drive system. A sporty, all-wheel-drive diesel wagon? Yes, please. Scroll down for the full press blast with all the details.