1996 Toyota Supra Twin Turbo Hatchback 2-door 3.0l on 2040-cars

Auto blog

US expands probe into ZF-TRW airbag failure-to-deploy to 12.3 million vehicles

DETROIT — U.S. auto safety regulators have expanded an investigation into malfunctioning airbag controls to include 12.3 million vehicles because the bags may not inflate in a crash. The problem could be responsible for as many as eight deaths. Vehicles made by Toyota, Honda, Kia, Hyundai, Mitsubishi and Fiat Chrysler from the 2010 through 2019 model years are included in the probe, which was revealed Tuesday in documents posted by the National Highway Traffic Safety Administration. It involves airbag control units made by ZF-TRW that were installed in the vehicles. The control units can fail in a crash, possibly because of unwanted electrical signals produced by the crash itself that can disable an air bag control circuit housed in the passenger compartment, according to NHTSA documents. The electrical signals can damage the control circuit, the documents say. ZF, a German auto parts maker which acquired TRW Automotive in 2015, said in a statement that it's committed to safety and is cooperating with NHTSA and automakers in the investigation. The case is another in a long list of problems with auto industry airbags, including faulty and potentially deadly Takata airbag inflators. At least 24 people have been killed worldwide and more than 200 injured by the inflators, which can explode with too much force and hurl dangerous shrapnel into the passenger cabin. The inflators touched off the largest series of automotive recalls in U.S. history involving with as many as 70 million inflators to be recalled by the end of next year. About 100 million inflators are to be recalled worldwide. On April 19, NHTSA upgraded the ZF-TRW probe from a preliminary evaluation to an engineering analysis, which is a step closer toward seeking recalls. So far, only Hyundai and Kia and Fiat Chrysler have issued recalls in the case. Four deaths that may have been caused by the problem were reported in Hyundai-Kia vehicles and three in Fiat Chrysler automobiles. NHTSA opened an investigation in March of 2017 involving the TRW parts in Hyundais and Kias. The upgrade came after investigators found two recent serious crashes involving 2018 and 2019 Toyota Corollas in which the airbags did not inflate. One person was killed. Jason Levine, executive director of the Center for Auto Safety, a nonprofit consumer group, said the ZF-TRW case shows the auto industry thus far has learned very little from Takata.

2020 Toyota Yaris hatchback could return as a Mazda2 clone

Less than a week ago we got the news that Toyota killed the 2019 Yaris Liftback in the U.S., instead choosing to sell the remaining inventory from 2018. There should be plenty of stock left, too: Car and Driver reports that Toyota sold 1,940 of the tiny hatches last year. The automaker said it would have an announcement about the Yaris at this year's New York Auto Show in April, telling Automobile, " We're working on something new for MY2020." C/D thinks it already knows what's coming, writing, "We assume ... that the new Yaris hatchback ... will be a rebadged Mazda2, like the current Yaris sedan that Mazda builds for Toyota in Mexico." Toyota and Mazda formed a development- and technology-sharing partnership in 2015. As part of the collaboration, we got the Scion iA in 2016, based on the Mazda2 sedan. That four-door became the Toyota Yaris iA when the Scion brand got put in the ground, and then became just the Yaris for 2019. In spite of Americans' well-publicized aversion to sedans, the trunked Yaris sold 25,269 units last year. Meanwhile, the Yaris hatch, built at a Toyota factory in France, has carried on basically untouched since 2013 — with a four-speed automatic, even — helping to explain its slow take-rate. If the Yaris five-door moves to the Mazda2 platform, we expect it to follow the same formula as the sedan. That means a 1.5-liter Skyactiv-G four-cylinder with 106 horsepower and 103 pound-feet of torque. That's the same output as the Toyota NR engine in the current hatch, but from a better, more modern engine. Transmission options would include a six-speed manual as standard on the L and LE trims. For 2019, Toyota added an XLE trim to the sedan that comes with a six-speed automatic. Assuming all comes to pass, the new Yaris five-door would be built at Mazda's Mexico plant alongside the sedan. But we'll have to wait until New York to know for sure. Related Video:

At least 15 states jockeying for Toyota and Mazda factory jobs

Just a few weeks ago, Mazda and Toyota announced a partnership that would lead to an all-new $1.6 billion plant here in the United States. The plant will build EVs and is expected to employ roughly 4,000 people directly while creating thousands of indirect jobs through suppliers, shipping and more. The Detroit Free Press reports that as many as 15 Midwestern and Southern states are understandably interested in striking a deal with the automakers. Most of the states already have ties to the auto industry. While the Midwest has traditionally been home to auto manufacturing in the United States, in the past 25 years or so, the South has made a big push, offering tax incentives and a union-free workforce. Alabama alone is home to facilities from Honda, Hyundai, Mercedes-Benz and Toyota. Others house a burgeoning tech or manufacturing industry ripe for the picking. Freep breaks down the pros and cons for each state, with much of the focus being on supply chains and a reliable and plentiful workforce. The latter is of particular concern in states like Alabama and Michigan that already have a big auto industry. Toyota may feel those areas have already been tapped for talent. Most of the states are along or adjacent to Interstate 75 and its extended roots, so others like Texas and Iowa will have to fight hard if they want this facility. It's only been a few weeks, though. With manufacturing jobs in such great demand and elected officials eager to show they're seeking them for their states, it wouldn't be surprising if a few more joined the fray. Related Video: This content is hosted by a third party. To view it, please update your privacy preferences. Manage Settings. News Source: Detroit Free Press Green Plants/Manufacturing Mazda Toyota