2014 Toyota Sienna Xle on 2040-cars

Auto blog

Toyota RAV4 EV recalled for Tesla motor assembly software problem

As we noted this morning, Toyota is recalling 112,500 cars and SUVs to fix problems with electric power steering controls and electric vehicle software. The largest of two recalls announced yesterday cover about 110,000 2015 Camry midsize sedans and Highlander SUVs, as well as 2014 and 2015 RAV4 SUVs. There is a specific problem for those RAV4s that are also of the electric variety, which Toyota built with Tesla help from 2012 through 2014. This recall covers 2,500 RAV4 electric vehicles. Software in a motor assembly can make the vehicles shift into neutral on their own. Toyota says it knows of no crashes or injuries that resulted from the problem. For the non-EV-specific recalls, Toyota says a circuit board in the electric power steering may have been damaged at the factory. Power-assisted steering could fail, increasing the effort needed to steer and raising the risk of a crash. Dealers will inspect and replace power steering controls if needed. Related Video: The AP contributed to this report. Featured Gallery 2012 Toyota RAV4 EV: First Drive View 22 Photos News Source: Bloomberg Green Recalls Tesla Toyota Electric rav4 ev toyota rav4 ev

Toyota recalls 337,000 RAV4s and HS250h models for tie rod failure

UPDATE: The post has been updated with additional information from NHTSA. The Basics: Toyota is recalling 337,000 2006-2011 model year Toyota RAV4 crossovers built between October 31, 2005 and September 7, 2010 as well as 2010 model year Lexus HS250h cars built between July 6, 2009 and August 26, 2010. The Problem: When either an affected RAV4 or HS250h is given an alignment and the tie rod adjustment nut on the rear control arm isn't tightened properly, the threads on the tie rod can start to rust. If this happens, the nut may break off and throw off the alignment drastically and suddenly. This isn't a case of the car simply pulling to one side, either. This would seriously upset the balance of the car and could cause the driver to lose control and crash. This is also the third time these vehicles have been recalled for the same issue. Injuries/Deaths: It's unknown if this control arm issue has resulted in any injuries or deaths. Autoblog reached out to Toyota for more information, but a company representative told us that the company isn't able to discuss injuries or deaths caused by this issue (if any) at this time. Based on information from NHTSA documents, it does not appear that any crashes, injuries or deaths have been attributed to the defect addressed in the current recall. The Fix: The dealer will completely replace the rear suspension assemblies at no cost to the owner. The tie rods and nuts will also be coated in epoxy to prevent future rusting from occurring. According to Car and Driver, the previous recalls involved tightening nuts, coating decent tie rods in epoxy and completely replacing rusted ones. The car magazine reports that further complaints were filed and the company is now replacing all components regardless of condition. If you own one: Toyota will notify owners of affected cars by mail. Owners can also check whether their cars are affected by entering the VIN at safercar.gov/vin. Owners with questions can also reach Toyota customer service at 1-800-331-4331 or Lexus customer service at 1-800-255-3987. Related Video: Featured Gallery 2012 Toyota RAV4 View 16 Photos News Source: Car and Driver, Toyota, National Highway Traffic Safety AdministrationImage Credit: Toyota Recalls Lexus Toyota Safety lexus hs 250h lexus hs250h

NHTSA urges owners of recalled Takata airbag vehicles to take immediate action

The National Highway Traffic Safety Administration and the Department of Transportation are taking the unusual step of issuing a followup press release urging owners of certain recalled vehicles "to act immediately" to fix their cars and trucks. The problem in question concerns the repair campaigns for rupturing Takata airbag inflators issued in June and covers a long list of models from Toyota, Lexus, Honda, Acura, Mazda, BMW, Nissan, Infiniti, Buick, Cadillac, Chevrolet, GMC, Oldsmobile and Pontiac.
While NHSTA doesn't specifically say why the recall is vital in the new release, Toyota's own explanation in its newly announced renotification campaign earlier today sheds some new light on the topic. According to the Japanese automaker, in testing, Takata found a possible link between the rupturing airbag inflators and high humidity. NHTSA is advocating that all owners pursue repairs immediately if they haven't already done so already. This is especially crucial for those drivers especially in Florida, Puerto Rico, Guam, Saipan, American Samoa, Virgin Islands and Hawaii because of the humid conditions there.
We don't need to tell you how dangerous an inadvertent airbag deployment could be - even in a stationary vehicle - but adding to the Takata issue is fears that the deployment could lead to shrapnel being sprayed into the cabin.