2002 Toyota Camry Le, 156k Miles, Great Car! (exc. For Fender/hood Bender) on 2040-cars

Auto blog

US expands probe into ZF-TRW airbag failure-to-deploy to 12.3 million vehicles

DETROIT — U.S. auto safety regulators have expanded an investigation into malfunctioning airbag controls to include 12.3 million vehicles because the bags may not inflate in a crash. The problem could be responsible for as many as eight deaths. Vehicles made by Toyota, Honda, Kia, Hyundai, Mitsubishi and Fiat Chrysler from the 2010 through 2019 model years are included in the probe, which was revealed Tuesday in documents posted by the National Highway Traffic Safety Administration. It involves airbag control units made by ZF-TRW that were installed in the vehicles. The control units can fail in a crash, possibly because of unwanted electrical signals produced by the crash itself that can disable an air bag control circuit housed in the passenger compartment, according to NHTSA documents. The electrical signals can damage the control circuit, the documents say. ZF, a German auto parts maker which acquired TRW Automotive in 2015, said in a statement that it's committed to safety and is cooperating with NHTSA and automakers in the investigation. The case is another in a long list of problems with auto industry airbags, including faulty and potentially deadly Takata airbag inflators. At least 24 people have been killed worldwide and more than 200 injured by the inflators, which can explode with too much force and hurl dangerous shrapnel into the passenger cabin. The inflators touched off the largest series of automotive recalls in U.S. history involving with as many as 70 million inflators to be recalled by the end of next year. About 100 million inflators are to be recalled worldwide. On April 19, NHTSA upgraded the ZF-TRW probe from a preliminary evaluation to an engineering analysis, which is a step closer toward seeking recalls. So far, only Hyundai and Kia and Fiat Chrysler have issued recalls in the case. Four deaths that may have been caused by the problem were reported in Hyundai-Kia vehicles and three in Fiat Chrysler automobiles. NHTSA opened an investigation in March of 2017 involving the TRW parts in Hyundais and Kias. The upgrade came after investigators found two recent serious crashes involving 2018 and 2019 Toyota Corollas in which the airbags did not inflate. One person was killed. Jason Levine, executive director of the Center for Auto Safety, a nonprofit consumer group, said the ZF-TRW case shows the auto industry thus far has learned very little from Takata.

Automakers want to stop the EPA's fuel economy rules change, and why that's a shortsighted move

With a Trump Administration looming, the EPA moved quickly after the election to propose finalizing future fuel economy rules last week. The auto industry doesn't like that (surprise), and has started making moves to stop the EPA. Ford CEO Mark Fields said he wanted to lobby Trump to lower the standards, and now the Auto Alliance, a manufacturer group, is saying it will join the fight against cleaner cars. The Alliance represents 12 automakers: BMW, Fiat Chrysler, Ford, GM, Jaguar Land Rover, Mazda, Mercedes-Benz, Mitsubishi, Porsche, Toyota, VW, and Volvo. Gloria Bergquist, a spokesperson for the Alliance, told Automotive News that the "EPA's sudden and controversial move to propose auto regulations eight months early - even after Congress warned agencies about taking such steps while political appointees were packing their bags - calls out for congressional action to pause this rulemaking until a thoughtful policy review can occur." The EPA was going to consider public comments through April 2017, but then said it would move the deadline to the end of December. That means that it can finalize the rules before President Obama leaves office. The director of public affairs for the Consumer Federation of America, Jack Gillis, said on a conference call with reporters last week when the EPA originally announced its decision that it is unlikely that President Trump will be able to roll back these changes. Gillis also said on the same call that any attempt by the automakers to prevent these changes would be history repeating itself. "These are the same companies that fought airbags, and now promoting the fact that every car has multiple airbags," he said. "These are the same companies that fought the crash-test program, and now are promoting the crash-test ratings published by the government. So, it's clear that they're misperceiving the needs of the American consumer." There are more reasons the Allliance's pushback is flawed. Carol Lee Rawn, the transportation program director for Ceres, said on that call that the automotive industry is a global one, and many automakers are moving to global platforms to help them meet strict fuel economy rules around the world.

2014 Toyota Aygo marks the spot [w/video]

Following the leaked pictures we showed you yesterday, we have the full battery of images and info of the all-new Toyota Aygo, in addition to our gallery of live photos from the floor of the Geneva Motor Show.
Like its cousins from Peugeot and Citroën, the Aygo foregoes a diesel engine in favor of a highly efficient gas powerplant. The 1.0-liter naturally aspirated 4-cylinder turns out 68 horsepower and 70 pound-feet of torque. When it hits the market, it'll be with either a five-speed manual transmission or a five-speed, X-Shift automated manual. The former will help the Aygo return 57.3 miles per gallon and hit 62 miles per hour in 14.2 seconds. Opting for the X-Shift variant will net drivers 56 mpg, with 62 arriving in a leisurely 15.5 seconds.
We'll admit, aside from the fuel efficiency, there's nothing terribly great about those numbers. Still, with its compact dimensions - it's only 136 inches long - and a curb weight of no more than 2,000 pounds, it should prove tossable in the bends.