Rav4 4wd V6 W/33k Miles on 2040-cars

Auto blog

The real reason automakers are giving away free hydrogen

Just like Hyundai did with its Tucson fuel cell, Toyota is offering free hydrogen fuel with the $57,500 Mirai H2 sedan. Toyota is being a bit vague about the details, saying simply that Mirai drivers will get, "complimentary hydrogen fuel for up to three years." Turns out, the reason that the hydrogen avant-garde will not be paying anything at the pump isn't because the automakers want to give them a boost or because the OEMs are kind. Instead, it's simply impossible to accurately charge people for hydrogen right now. It's simply impossible to accurately charge people for hydrogen right now. At an in-depth hydrogen seminar this week as part of the Mirai preview, three representatives from various hydrogen organizations revealed that the current hydrogen stations (most of which are in California) are not set up to accurately measure the hydrogen that is dispensed. Without this little bit of information, you can't charge customers for the fuel they use. Toyota is well aware of this, and Toyota Motor Sales' national manager of environmental, safety and quality communications, John Hanson, said that, "There are no set standards, so there is no way to charge people for anything." Alberto Ayala, the deputy executive officer for the California Air Resources Board, said CARB is in the middle of developing a way to sell a given amount of hydrogen, "which up to this point doesn't exist. If you think about it, it's a real simple yet real practical challenge. If you're going to pay for X amount of hydrogen, you're actually getting that amount of hydrogen." Ayala said it's not a difficult technical problem to measure the hydrogen as it goes into the car, but "we just have not done it. We are at a point where we are solving multiple remaining questions [with hydrogen infrastructure], and that just happens to be one of them." The National Institute of Standards and Technology says that there has been a discussion to change the current tolerance of two percent up to 10 or 20 percent, but that new technology should be able to measure accurately to within one percent. Air Liquide is working with Toyota to launch the Mirai in the US and Air Liquide CEO Ole Hofelmann told AutoblogGreen that being able to charge customers will be key to the technology's success. "We need to make sure we accurately measure the gas," he said.

Toyota recalls 370k Sienna minivans, 10.5k Lexus GS models over separate issues

The year of the recall continues, but this time it isn't from General Motors. Toyota is announcing two, separate recalls affecting a pair of its models.
First, Toyota is recalling 370,000 Sienna minivans from the 2004 to 2011 model years that are registered or originally sold in cold-weather states. The problem is that the spare tire carrier assembly cable can be splashed by water contaminated with road salt and cause corrosion. There is a splashguard in place to prevent this, but it sometimes gets lost in "normal usage," according to the company. If the cable does break, then "the spare tire may separate from the vehicle."
This is actually the second repair for this problem for some of these vehicles. In 2010, Toyota issued a recall on 600,000 Siennas from the 1998 to 2010 model years. At the time, it installed a new splashguard and sprayed the area with an anti-rust chemical. However, according to Toyota spokesperson John Hanson speaking to Autoblog, the campaign worked for the 1998 to 2003 models but wasn't sufficient for the newer ones. For the latest recall, the vehicles are getting the entire cable replaced with a stainless steel unit and a new splashguard.

Brand new cars are being sold with defective Takata airbags

If you just bought a 2016 Audi TT, 2017 Audi R8, 2016–17 Mitsubishi i-MiEV, or 2016 Volkswagen CC, we have some unsettling news for you. A report provided to a US Senate committee that oversees the US National Highway Traffic Safety Administration (NHTSA) and reported on by Automotive News claims these vehicles were sold with defective Takata airbags. And it gets worse. Toyota and FCA are called out in the report for continuing to build vehicles that will need to be recalled down the line for the same issue. That's not all. The report also states that of the airbags that have been replaced already in the Takata recall campaign, 2.1 million will need to eventually be replaced again. They don't have the drying agent that prevents the degradation of the ammonium nitrate, which can lead to explosions that can destroy the airbag housing and propel metal fragments at occupants. So these airbags are out there already. We're not done yet. There's also a stockpile of about 580,000 airbags waiting to be installed in cars coming in to have their defective airbags replaced. These 580k airbags also don't have the drying agent. They'll need to be replaced down the road, too. A new vehicle with a defective Takata airbag should be safe to drive, but that margin of safety decreases with time. If all this has you spinning around in a frustrated, agitated mess, there's a silver lining that is better than it sounds. So take a breath, run your fingers through your hair, and read on. Our best evidence right now demonstrates that defective Takata airbags – those without the drying agent that prevents humidity from degrading the ammonium nitrate propellant – aren't dangerous yet. It takes a long period of time combined with high humidity for them to reach the point where they can rupture their housing and cause serious injury. It's a matter of years, not days. So a new vehicle with a defective Takata airbag should be safe to drive, but that margin of safety decreases with time – and six years seems to be about as early as the degradation happens in the worst possible scenario. All this is small comfort for the millions of people who just realized their brand-new car has a time bomb installed in the wheel or dashboard, or the owners who waited patiently to have their airbags replaced only to discover that the new airbag is probably defective in the same way (although newer and safer!) as the old one.