2014 Toyota Prius Three on 2040-cars

Auto blog

Toyota and Lexus recalling 235,000 hybrid CUVs and sedans over separate issues

When it rains, it pours. Toyota has announced a pair of separate but voluntary North America recalls covering approximately 235,000 vehicles built between 2006 and 2011. The larger of the two recalls targets Toyota's hybridized crossovers, the Lexus RX400h and Toyota Highlander Hybrid. 133,000 units, including 2006-2010 Highlander and 2006-2008 RX crossovers are covered in the campaign. The other recall affects 102,000 IS350 sedans, IS350C convertibles and GS350 sedans built between 2006 and 2011.
With the CUVs, the faults in the parallel circuits of the transistors can cause heat damage in the inverter assembly, triggering an abundance of warning lamps and sending the vehicle into limp mode. The Lexus sedans are being recalled due to loose bolts on the variable valve timing controller. Detected by unusual underhood sounds on startup, the issue can cause the engine to stop while driving. The inverter issue is also triggering similar recalls in Japan and Europe.
At the moment, it's unclear if any of these issues have caused any crashes or injuries. Toyota says it plans to notify owners of the recall via snail mail. Additional information for owners can be found on the recall sites for Toyota and Lexus or by calling Toyota's customer service line, at 1-800-331-4331. Scroll down for the complete recall notice from Toyota.

Toyota Recalling 516,000 Vehicles In Three Recalls

Toyota said Thursday it's recalling 516,000 vehicles worldwide - including 430,500 in the U.S. - for three separate safety problems, including brakes that can activate without warning. The company said it has no reports of accidents or injuries due to the defects. In all three cases, the company will alert owners and dealers will repair the issues for free. The largest recall, of 450,000 Sienna minivans from the 2004-2011 model years, targets vehicles sold in cold weather areas. Toyota said road salt can corrode the spare tire carrier under the vehicle and the tire can fall off. Siennas from the 2004-2010 model years were for the same issue in 2010, and a splash protector and anti-rust protection were applied. But the company says the splash protector can fall off and rust can still occur. The recall involves 370,000 minivans sold in the U.S., 80,000 in Canada and 400 in Europe. Also recalled Thursday were: - 16,000 Lexus GS 250 and 350 sedans from the 2013 model year because a manufacturing defect can cause the brakes to activate without warning, and without turning on the brake lights. Most of the vehicles - 10,500 - were sold in the U.S. Also included are left-hand-drive sedans sold in Canada, China and Europe. - 50,000 Highlander and Highlander hybrid SUVs from the 2014 model year. Toyota says a software glitch may prevent the vehicle from properly calculating the size of the front passenger when determining whether to fire the air bags. The affected vehicles assume the passenger is smaller, so the bags may not fire or they may fire at a lower speed than necessary for a larger passenger. Toyota says most of the affected vehicles - 45,287 - were sold in the U.S. Around 3,400 were sold in Canada and the rest were sold in Mexico and Europe. Related Gallery AOL Autos Test Drive: 2014 Toyota Highlander Recalls Toyota

Toyota, Daihatsu and Suzuki team up to unbox some fun-size electric kei vans

The G7 Summit is happening in Hiroshima, Japan, right now and some automakers have taken the opportunity to announce new projects. Toyota, their wholly owned subsidiary Daihatsu, and Suzuki (of which Toyota owns about 5%) made news with a trio of electric micro-vans built to kei car specifications. The battery-electric vans are part of an industry-wide push toward carbon neutrality. Kei-class vehicles, in addition to limited displacement gasoline engines, have strict dimensional restrictions that allow them to navigate the often narrow streets in dense urban areas. They're also privilege to certain tax breaks and parking benefits.  [gallery ids="2474953,2474954"] The engine size rules obviously don't apply to the electric vans, but they will still conform to the size boundaries. Kei vans are often used to solve the "last mile" problem in logistics since they're able to whiz around crowded streets inaccessible by larger commercial vehicles.  Daihatsu, which specializes in kei cars, will build the vans and name their variant the HiJet Cargo. The HiJet name has been a consistent one in the company's lineup since 1960, but these new versions will be front-wheel-drive in contrast to the rear-wheel-drive gasoline variants. Toyota's version will be called the Pixis Van, while Suzuki will be named the Every, a nameplate that's been around since 1982. Aside from the badges the vans appear identical. Range is said to be approximately 200km (124 miles) on a single charge.  The exhibition was held in conjunction with the Japan Automobile Manufacturers Association, which former Toyota CEO Akio Toyoda heads. Toyoda stepped down from the top position at the company his grandfather founded in April, but still takes a overseer role as Chairman. Toyoda was criticized for being slow to adopt EVs, and new CEO Koji Sato has emphasized the role of battery-electrics moving forward while still taking a multi-front approach to carbon neutrality with hydrogen and hybrids. These vans were likely in development before Toyoda's retirement, though.