2011 Toyota Corolla on 2040-cars

Auto blog

Toyota recalls 52k units of 2011-2012 Avalon for potential short circuit

Toyota is issuing a recall for roughly 52,000 examples of its 2011 and 2012 Avalon sedans in the US because a possible short circuit in the wiring for audio system's subwoofer may cause a fire. According to Toyota, it's possible for the subwoofer's wires to move out of position if contacted by cargo in the trunk. If one of the wires then contacts the metal frame of the speaker, it could trigger a short circuit. "If this occurs, the subwoofer could overheat, increasing the risk of a fire," according to the automaker. "There were two reports of thermal events – no outright fires," said Toyota spokesperson Cindy Knight to Autoblog. Toyota reports there are no reports of injuries, fatalities or crashes from this problem. Dealers will repair this problem at no cost, but until then, they will immediately disconnect the rear subwoofer as a precaution for owners. The recall notices will be sent out in mid-February, according to Knight. TOYOTA RECALLS CERTAIN 2011-2012 MODEL YEAR AVALON VEHICLES TORRANCE, Calif., January 28, 2015 – Toyota Motor Sales, U.S.A., Inc., today announced plans to conduct a safety recall of approximately 52,000 Model Year 2011-2012 Avalon sedans. In the involved vehicles, cargo could contact one of the audio system subwoofer wires located inside the trunk, and move the wire out of its normal position. If one of these wires contacts the metal frame of the subwoofer, it may result in an intermittent short circuit. If this occurs, the subwoofer could overheat, increasing the risk of a fire. Toyota is not aware of any crashes, injuries, or fatalities caused by this condition. Owners of the involved vehicles will receive a notification by first class mail. Toyota dealers will provide a repair for the audio system. Until the remedy is available, as a precaution, Toyota dealers will disconnect the rear subwoofer. Detailed information is available at www.toyota.com/recall and by calling Toyota Customer Service at 1-800-331-4331. ###

US expands probe into ZF-TRW airbag failure-to-deploy to 12.3 million vehicles

DETROIT — U.S. auto safety regulators have expanded an investigation into malfunctioning airbag controls to include 12.3 million vehicles because the bags may not inflate in a crash. The problem could be responsible for as many as eight deaths. Vehicles made by Toyota, Honda, Kia, Hyundai, Mitsubishi and Fiat Chrysler from the 2010 through 2019 model years are included in the probe, which was revealed Tuesday in documents posted by the National Highway Traffic Safety Administration. It involves airbag control units made by ZF-TRW that were installed in the vehicles. The control units can fail in a crash, possibly because of unwanted electrical signals produced by the crash itself that can disable an air bag control circuit housed in the passenger compartment, according to NHTSA documents. The electrical signals can damage the control circuit, the documents say. ZF, a German auto parts maker which acquired TRW Automotive in 2015, said in a statement that it's committed to safety and is cooperating with NHTSA and automakers in the investigation. The case is another in a long list of problems with auto industry airbags, including faulty and potentially deadly Takata airbag inflators. At least 24 people have been killed worldwide and more than 200 injured by the inflators, which can explode with too much force and hurl dangerous shrapnel into the passenger cabin. The inflators touched off the largest series of automotive recalls in U.S. history involving with as many as 70 million inflators to be recalled by the end of next year. About 100 million inflators are to be recalled worldwide. On April 19, NHTSA upgraded the ZF-TRW probe from a preliminary evaluation to an engineering analysis, which is a step closer toward seeking recalls. So far, only Hyundai and Kia and Fiat Chrysler have issued recalls in the case. Four deaths that may have been caused by the problem were reported in Hyundai-Kia vehicles and three in Fiat Chrysler automobiles. NHTSA opened an investigation in March of 2017 involving the TRW parts in Hyundais and Kias. The upgrade came after investigators found two recent serious crashes involving 2018 and 2019 Toyota Corollas in which the airbags did not inflate. One person was killed. Jason Levine, executive director of the Center for Auto Safety, a nonprofit consumer group, said the ZF-TRW case shows the auto industry thus far has learned very little from Takata.

2014 Toyota Corolla and Tundra production underway

After months of leaked photos and speculative reports, Toyota finally unveiled its 2014 Corolla to the world in early July at a star-studded California party. The confetti has been swept up and the champagne flutes washed and stored, and now the real work can begin: production. Toyota has announced that its new C-segment player has begun rolling off the lines at its plants in Mississippi and Ontario, Canada this week ahead of the planned start of sales in September. What's more, the refreshed 2014 Tundra pickup has also segued into production in San Antonio, Texas.
Corolla production in Mississippi is still a relatively recent phenomenon, with the plant having begun assembly of the outgoing model in the fourth quarter of 2011, while Toyota's Cambridge, Ontario plant has been churning out the compact volume king since 1988. Conversely, the Tundra has been in production at the Texas facility since 2006, and Toyota projects that the plant will build its milestone one-millionth new vehicle in September, right around the time the reworked fullsize pickup goes on sale.