2013 Toyota 4runner Sr5 on 2040-cars

Auto blog

Brand new cars are being sold with defective Takata airbags

If you just bought a 2016 Audi TT, 2017 Audi R8, 2016–17 Mitsubishi i-MiEV, or 2016 Volkswagen CC, we have some unsettling news for you. A report provided to a US Senate committee that oversees the US National Highway Traffic Safety Administration (NHTSA) and reported on by Automotive News claims these vehicles were sold with defective Takata airbags. And it gets worse. Toyota and FCA are called out in the report for continuing to build vehicles that will need to be recalled down the line for the same issue. That's not all. The report also states that of the airbags that have been replaced already in the Takata recall campaign, 2.1 million will need to eventually be replaced again. They don't have the drying agent that prevents the degradation of the ammonium nitrate, which can lead to explosions that can destroy the airbag housing and propel metal fragments at occupants. So these airbags are out there already. We're not done yet. There's also a stockpile of about 580,000 airbags waiting to be installed in cars coming in to have their defective airbags replaced. These 580k airbags also don't have the drying agent. They'll need to be replaced down the road, too. A new vehicle with a defective Takata airbag should be safe to drive, but that margin of safety decreases with time. If all this has you spinning around in a frustrated, agitated mess, there's a silver lining that is better than it sounds. So take a breath, run your fingers through your hair, and read on. Our best evidence right now demonstrates that defective Takata airbags – those without the drying agent that prevents humidity from degrading the ammonium nitrate propellant – aren't dangerous yet. It takes a long period of time combined with high humidity for them to reach the point where they can rupture their housing and cause serious injury. It's a matter of years, not days. So a new vehicle with a defective Takata airbag should be safe to drive, but that margin of safety decreases with time – and six years seems to be about as early as the degradation happens in the worst possible scenario. All this is small comfort for the millions of people who just realized their brand-new car has a time bomb installed in the wheel or dashboard, or the owners who waited patiently to have their airbags replaced only to discover that the new airbag is probably defective in the same way (although newer and safer!) as the old one.

177k Toyota Camry Hybrids being recalled for brake issue

It looks like Consumer Reports might be getting part of what it wants regarding the Toyota Camry Hybrid and its braking system. Toyota is issuing what it calls a limited service campaign, rather than a full recall, covering about 177,500 of the hybrid sedans from the 2007 through 2011 model years because of an issue with the cars' brake fluid reservoirs.
The models have a filter separating two chambers of the brake fluid reservoir, and the part can get clogged over time. If this happens, the fluid level in one of the chambers can get too low and eventually cause the power assist to fail. There are multiple warning lights on the dashboard that illuminate over time if the filter gets obstructed, though. The company is replacing the entire reservoir with an improved unit, and the fix takes about two hours to perform.
Consumer Reports recently began asking for a recall on these models for the potentially clogged filters. The magazine also reported a second issue with the ABS brake actuator that could lead to a difficult to depress brake, but Toyota has increased the warranty on the part to 10 years or 150,000 miles.

Toyota, Mazda $1.6 billion plant goes to Alabama, sources say

Alabama will be the site of a new $1.6 billion Toyota and Mazda auto plant, a victory for President Donald Trump who had prodded manufacturers to build new U.S. facilities and threatened tariffs on foreign production, sources said on Tuesday. The plant, which will employ up to 4,000 people and produce about 300,000 vehicles a year, will be located in Huntsville, Ala., and is a boon for the state, where Toyota has a large engine plant and an existing network of automotive suppliers. A formal announcement by company and state officials is expected on Wednesday in Montgomery, sources briefed on the matter said. The new plant — in a state Trump won by 28 points in 2016 — could be a political boost to the Republican president, who has urged automakers to build plants in the United States and add jobs. The companies said they expect the plant to open in 2021. Trump tweeted in March he wanted "new plants to be built here for cars sold here." The White House did not immediately comment on Tuesday. The announcement also comes at a time of declining U.S. auto industry sales, so it could exacerbate overcapacity and add pressure to cut prices. U.S. new vehicle sales fell 2 percent in 2017, after hitting an all-time record high in 2016, and are expected to fall further in 2018. Details of an anticipated tax and incentive package for the investment were not yet known. It has been reported the companies sought at least $1 billion in incentives. A Toyota spokesman declined to comment, except to say an announcement was expected soon. A Mazda spokeswoman also declined to comment. In recent months, the companies had narrowed their choices down to sites in Alabama and North Carolina. Local media last month said the leading site under consideration was in northern Alabama's Limestone County, near Toyota's large engine plant in Huntsville. In September, Toyota announced a $106 million technology upgrade for the Huntsville plant. A Chamber of Commerce of Huntsville website for the "Huntsville Mega Site" touts the fact it has been "certified as development-ready." The commerce chamber, local and state officials declined to comment on Tuesday on plans for the plant. A year ago, President-elect Trump criticized Toyota and threatened hefty tariffs against the Japanese automaker if it built its Corolla sedan for the U.S. market in Mexico. "Toyota Motor said will build a new plant in Baja, Mexico, to build Corolla cars for U.S. NO WAY! Build plant in U.S.