2004 Saturn Ion-2 Base Sedan 4-door 2.2l on 2040-cars

Auto blog

Saturn Ion steering probe closed by NHTSA

The National Highway Traffic Safety Administration has closed its investigation into faulty electric power steering motors affecting 334,728 Saturn Ions from 2004-2007, because General Motors has issued a recall for them. The group's research found that the part failed at a high rate in the vehicles.
GM recalled over 1.3 million vehicles a few weeks ago, including the Ion, because the power steering could suddenly fail. If broken, the cars could still turn, but it took greater effort. The automaker is also covering 96,324 2003 Ions with a lifetime warranty for their motors, but it's not immediately replacing them.
NHTSA opened its investigation into the motors in September 2011, and it found 4,787 complaints and 30,560 warranty claims that showed failure for the Ion alone. It estimated a complaint rate of 14.3 incidents per 1,000 vehicles and warranty claim rate of 9.1 percent. The investigation also found evidence of 12 crashes caused by loss of steering, two of which resulted in injuries.

Junkyard Gem: 2007 Saturn Sky

The Pontiac Division didn't have long to live when the Solstice first appeared in 2005 as a 2006 model, and Saturn's head was inching toward the chopping block at about the same rate. Still, optimism reigned — at least, it did until the global economy fell apart — and so Saturn Dealers got a rebadged version of the Solstice to sell: the Sky. Available for just the 2007 through 2010 model years, slightly more than 34,000 Skies rolled out of showrooms before the doors were nailed shut. Here's one of those rare cars, found in a Denver-area self-service yard a few weeks ago. I've found a handful of discarded Solstices in car graveyards during the past few years, mostly with crash damage. This Sky endured a medium-hard impact in the right front corner, which sent it to this place. The 177-horsepower, 2.4-liter Ecotec still resides under the battered hood. The Sky Redline version had a turbocharged engine rated at 260 horses; we can assume that such an engine would be yanked and purchased by the first junkyard shopper that realized what it was. The base transmission in the Sky was an Aisin five-speed manual, but this car has the optional five-speed automatic.  The Sky had its own nose and some different badging, but otherwise didn't differ much from the Solstice.  For the South Korean market, the Sky got Daewoo G2X badges and was advertised as the ideal vehicle for high-speed chases through Seoul traffic. The same car went to Europe as the Opel GT. Sadly, GM ran out of money to make right-hand-drive Skies, so we never got to witness Holden or Vauxhall versions. Here's Bob Lutz describing the new Sky. Lutz really hated car names molded into plastic bumper covers, so he takes great care here to describe the genuine glued-on emblems. Related Video:

303 Deaths Tied To Airbag Non-Deployment In 2 General Motors' Cars

At least 303 motorists died in car accidents after their airbags didn't deploy in now-recalled General Motors vehicles, according to a study released late last night. The Center for Auto Safety, a non-profit automotive watchdog, reviewed data from the Fatality Analysis Reporting System, and counted deaths involving the Chevrolet Cobalt and Saturn Ion, two vehicles at the heart of several ongoing investigations, to reach its conclusion. If the airbag non-deployments were the result of a faulty ignition switch that inadvertently turns them off, the death toll would be the largest in automotive history attributed to a single defect, surpassing the 250 deaths investigators linked to defective Firestone Tires more than a decade ago. The rising death toll would further amplify questions about why GM and federal safety regulators at the National Highway Traffic Safety Administration didn't act sooner to correct the problem. Safety advocates have said both GM and NHTSA failed to act in a timely fashion to alert motorists of the dangers posed by the dangerous defect, of which documents GM had knowledge of as early as 2001 and NHTSA knew about in 2007. "The question today for NHTSA is how so many ... death reports without an airbag deployment and so many FARS deaths without an airbag deployment failed to trigger an investigation," wrote Clarence Ditlow, the executive director of the Center for Auto Safety. "... For the people who died or were seriously injured in crashes, the answer comes too late." GM has acknowledged 13 deaths related to the problem, and says the number cited by the Center for Auto Safety study is "speculation." The review of FARS data, conducted by Friedman Research at the request of the Center for Auto Safety, looked at fatal cases in which airbags did not deploy but did not analyze the causes of the crashes. FARS information is raw data submitted to a national database by state and local authorities when fatal accidents occur. Last month, GM recalled 1.37 million cars in the U.S. because a faulty ignition switch had been inadvertently moving from the "run" position to the "accessory" position, turning off engines and systems that provide power to airbags. "Shame is not a strong enough word," said Lou Lombardo, the founder of Care for Crash Victims, another safety-minded nonprofit that advocates for accident victims. The results of the CAS study were first reported by the New York Times.