2023 Ram Promaster High Roof on 2040-cars

Auto blog

Ram recalling 65k trucks for rear-axle heat treating

A problem with the rear axle has promoted Fiat Chrysler Automobiles to recall a selection of Ram trucks. The campaign affects 2015-16 Ram 1500 series trucks – specifically those manufactured between June 17 and September 28, 2015. All told, that amounts to over 65,760 units across the United States. The issue stems, according to the statements below, from the rear axle shaft. Some of those trucks may have not had those axle shafts properly heat-treated, which could cause them to fracture and separate from the wheel. And that, it should go without saying, could lead to a crash. FCA states that most of the vehicles in question are in dealer hands, but while the manufacturer says it is aware of one accident to have resulted from the issue, no injuries have been reported. The owners of the affected vehicles will be notified to bring their trucks in to their local dealership to have them inspected. If necessary, the dealership with replace the rear axle assembly. This recall follows three prior (but unrelated) ones, also issued for Ram pickups, that between them affected well over a million units. Related Video: RECALL Subject : Incorrectly Heat Treated Rear Axle Shaft Report Receipt Date: OCT 15, 2015 NHTSA Campaign Number: 15V661000 Component(s): POWER TRAIN Potential Number of Units Affected: 65,760 Manufacturer: Chrysler (FCA US LLC) SUMMARY: Chrysler (FCA US LLC) is recalling certain model year 2015-2016 Ram 1500 trucks manufactured June 17, 2015, to September 28, 2015. The affected vehicles may have been built with rear axles that were incorrectly heat treated. CONSEQUENCE: If the rear axle shaft was not properly heated treated, it may fracture and a wheel separation could occur, increasing the risk of a crash. REMEDY: Chrysler will notify owners, and dealers will inspect the vehicles and replace the axle assemblies, as necessary, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R59. NOTES: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. ### Statement: Heat-treating October 27, 2015 , Auburn Hills, Mich. - FCA US LLC is voluntarily recalling an estimated 65,760 U.S.-market trucks – most of which are in dealer hands – to inspect and replace, as required, their rear axle shafts or rear axles.

2019 Ram 1500 North Edition is bundled up for winter

The 2019 Ram 1500 North Edition combines a host of features into a special edition meant to keep the abominable winter at bay. Based on the Big Horn trim, which sits just above the base Tradesman, Ram says the North Edition is "geared toward truck owners who need more capability and warmth on their frozen drive." The means 4x4 only, with your choice of crew cab or quad cab, 5'7" bed or 6'4" bed, and either the 3.6-liter Pentastar eTorque or or the 5.7-liter Hemi V-8 with or without eTorque. To that canvas, Ram adds some of the features from the Off-Road package, including heavy duty shocks with a one-inch lift, locking rear axle, and tow hooks. Weapons against the cold include an engine block heater, and Level 2 Package options like heated seats and steering wheel, heated and folding mirrors, and remote start for pre-warming the cabin. There are individual extras, like the 12-way power driver's seat with four-way lumbar support, instead of the eight-way seat normally part of the Level 2 package. Snow service-rated, three-peak mountain snowflake (3PMSF) Falken LT tires toil outside to keep the rubber on the road; the standard Off-Road package uses Falken All-Terrains (AT3WA). Mopar floor mats toil inside to keep slush and grime from spoiling a good time. A monochromatic appearance package paints all the exterior trim pieces one hue. One splash of contrast comes with the 4x4 decal along the flanks, the other is what looks like a set of 20-inch, six-spoke wheels. The Ram press release didn't mention the special rims, but on the configurator, when we clicked the 20-Inch x 9.0 Aluminum Chrome-Clad Wheels, we were forced to add the North Edition package. As of writing, the configurator pricing appears to be at odds with the MSRP stated in the press release. Start with the $41,490 Ram 1500 Big Horn 4x4 on the build site, add the North Edition package, and the price shows as $45,285 before a $1,695 destination charge. Ram says the truck is available at dealers now, but lists an MSRP of $45,890 before destination. There's a $605 difference between the two numbers. The build site doesn't pre-select the 20-inch wheels with the North Edition package, though. Normally a $1,595 option, adding the wheels to the build raises the price by $200, to $45,285, leaving a $405 difference. Point being, assume the dealer will start the bargaining with the $45,890 price.

The EPA has alleged that FCA installed undisclosed emissions software in about 100k Ram and Jeep diesel models [UPDATE]

Update: The text has been updated with official information from the EPA given in a press release and a conference call. Although an initial report from Reuters said the EPA will accuse Ram and Jeep of using emissions defeat devices today, that isn't quite the case. In a press release and a conference call, the EPA stated that the notice of violation sent to FCA is for the installation of eight undisclosed auxiliary emissions control devices on 2014 to 2016 Jeep Grand Cherokee and Ram 1500 models with the 3.0-liter turbodiesel V6. The violation applies to about 104,000 vehicles in total. The agency also explained that auxiliary emissions controls on vehicles are not necessarily illegal, but installing them without disclosing them to the EPA when having the vehicle certified is. Though this initial notice of violation is for installing undisclosed software, the EPA may soon also classify these emissions devices as defeat devices, as it did with the software Volkswagen used. Depending on the outcome of the investigation, there could be fines of up nearly $45,000 per vehicle involved in the notice of violation. The agency revealed that the software alters how the emissions system performs in certain situations. In controlled testing, the vehicles are compliant, but in conditions such as high speed operation, the EPA found the vehicles would produce much higher levels of NOx emissions. The EPA is continuing to investigate, and is waiting for FCA to explain why these emissions control devices are not cheating or defeat devices. In an official statement, FCA stated it is looking forward to explaining that the software does not constitute a defeat device, and has also proposed software updates to achieve compliance. During the conference call, EPA representatives also noted that the vehicles are still safe and legal to be driven, and that owners do not need to take any action yet regarding their cars. It should be noted there is no stop-sale on current models at this time. Additionally, 2017 versions of the 3.0-liter diesel FCA vehicles have not been emissions certified yet. Related Video: News Source: Reuters, Environmental Protection Agency Government/Legal RAM