4.6l Sunroof Stability Control Electronic Impact Sensor Fuel Cut-off Suspension on 2040-cars

Auto blog

Ford and Lincoln recall about 170,000 vehicles over defective rear-view camera

Ford and Lincoln have jointly issued a safety recall that includes nearly 170,000 vans and SUVs built between the 2018 and 2023 model years. The vehicles included in the campaign are equipped with a rear-view camera whose image can cut out while the driver is backing up. Assigned recall number 23V-598 by the National Highway Traffic Safety Administration (NHTSA), the campaign includes the following cars: 7,649 units of the 2020-2023 Aviator fitted with the standard rear-view camera and built from October 19, 2019, to August 17, 2023. 70,600 units of the 2018-2021 Navigator fitted with the 360-degree camera and built from March 16, 2017, to December 23, 2021. 66,740 units of the 2022-2023 Transit fitted with either camera system and built from February 26, 2021, to August 17, 2023. 24,468 units of the 2021 Bronco fitted with the 360-degree camera and built from September 23, 2020, to December 22, 2021. Ford explains that the defect is present in all of the 169,277 vehicles included in the campaign. While these are different cars equipped with different technology, they all suffer from the same problem. The company explains that "customers may intermittently experience either a rear camera blue image or a full blue or black image on the SYNC [infotainment system] screen when the vehicle is placed in reverse, or when the 360-degree view is selected and available." It adds that losing the camera's image while backing up increases the risk of the crash. The cause of the problem varies from model to model. Ford has narrowed it down to the camera hardware, the wiring retention, and the Image Processing Module - V (IPMB) software. It adds that "fretting corrosion causes tin oxide formation on the internal camera connector due to [a] thermally-induced micro-movement between the tin-plated contact surfaces," and that the rate of tin oxide accumulation depends on factors such as the temperature and the humidity. It has also traced some of these issues to a problem during the manufacturing process. Ford will begin notifying owners of affected vehicles by mail on October 2. When parts are available, owners will be asked to bring their van or SUV to an authorized dealer so that a technician can replace the rear-view camera. Transit models included in the campaign will also receive a software update. Owners who have already paid to fix the problem can claim a reimbursement until June 30, 2024. This isn't Ford's first rear-view camera-related recall.

2020 Ford Explorer safer than old model; crash test ratings short of Top Safety Pick

The 2020 Ford Explorer three-row crossover has improved on the outgoing model in many ways. According to the IIHS, it has also improved in a number of safety categories, but not enough to earn a Top Safety Pick award. The culprit is not the headlight performance for once. The Explorer's headlights were given an "Acceptable" rating, which would be sufficient for Top Safety Pick, if not Top Safety Pick +. Where the Ford falls short is in the front small overlap driver-side crash test, in which it got the second highest "Acceptable" rating. The IIHS requires a "Good" rating in this category, whereas an "Acceptable" rating on the passenger side would be, well, acceptable for Top Safety Pick. According to IIHS, Ford will be reviewing the results to figure out what the issue is, and it will likely make revisions to future Explorers to improve the result. Other than the one test, the Explorer performed admirably. It received a "Good" rating in all other crash categories except the passenger-side small overlap that was not tested. Both its standard and optional forward collision prevention systems had the highest "Superior" ratings, with the standard one preventing a collision with a car at speeds of up to 25 mph, and the optional one avoiding a collision at 12 mph, and "nearly" preventing one at 25 mph. Headlights are rated as "Acceptable" and so is access to child seat LATCH anchors. Also worth noting is that the Explorer's crash test ratings apply to its luxurious twin the 2020 Lincoln Aviator, meaning it also doesn't get a Top Safety Pick rating. The forward collision system performed the same as in the Ford, and the only difference between the two was in headlight performance. The Lincoln's standard headlights, included on the base, Reserve and Grand Touring trims, have the second-lowest "Marginal" rating, but the optional headlights for those trims, and the standard ones on the Black Label trim, received the "Good" rating. Among three-row Explorer competitors, the Honda Pilot, Hyundai Santa Fe XL, Kia Telluride, Nissan Pathfinder and Toyota Highlander all have a Top Safety Pick. The Hyundai Palisade, Mazda CX-9, Subaru Ascent, and the slightly smaller Kia Sorento and Volkswagen Tiguan all have a Top Safety Pick +. As for Lincoln Aviator competitors, the Cadillac XT6, Infiniti QX60, Lexus RX and Volvo XC90 get a Top Safety Pick. The Mercedes-Benz GLE-Class and two-row-only BMW X5 get the Top Safety Pick + rating. Related Video:      

Lincoln revival bypasses rear-wheel drive for now

Ford execs had the axe ready for Lincoln just a few years ago, but the luxury marque is on a hot streak these days. Annual sales are up 7.5 percent through October, and the recently unveiled, refreshed 2017 MKZ previews the company's improved styling. In a great piece about the brand's growth strategy, Automotive News finds the division's bosses want to focus on the core vehicles before taking a big step and building a rear-wheel drive niche model. "Luxury coupes and sports cars are not the first place we need to go," Global Lincoln Director Matt VanDyke said in the story. The division's bosses want to use the updated MKZ as an opportunity to distance Lincoln's identity from Ford, and the powertrain will carry the 3.0T badge rather than Ford's EcoBoost name as part of that approach. The model also injects excitement into the range thanks to an all-wheel drive version with a 3.0-liter twin-turbo V6 with 400 horsepower and an optional Driver's Package with a torque-vectoring rear differential. Lincoln will launch at least three new models by 2020, too. One of those will be the production Continental that will reportedly debut at the Detroit Auto Show. The company will also allegedly revive the Aviator to fit below the Navigator. The third vehicle remains a mystery but likely isn't a compact. Automotive News' story further examines the previously languishing brand's work to climb up the luxury ranks in the US. It's well worth a read. Related Video: