2006 Lincoln Mark Lt Not Ford F 150 4x4 on 2040-cars

Auto blog

2017-19 Ford Super Duty trucks recalled for tailgates that could open

Ford announced two separate recalls today, though neither has resulted in any known injuries. The first recall, which deals with a tailgate malfunction, affects 261,617 examples of 2017-2019 F-250, F-350, and F-450 Super Duty pickups. The second, which anticipates the possibility of a fuel leak, affects 3,893 units of 2020 Explorer and 2020 Lincoln Aviator SUVs with 3.0-liter engines. Ford says tailgates might accidentally open on some 2017-2019 Super Duty trucks because of a short circuit. If the pickups have an electric tailgate latch-release switch on the tailgate handle, water might get into the wiring. If the water hits the right spots, a short circuit could cause the switch to release the tailgate latch. In a worst-case scenario where the tailgate opens while driving, contents of the truck's bed could fall out and create a safety hazard. Dealerships will fix the problem by modifying the tailgate frame wiring harnesses with jumper pigtails and install a new tailgate handle release switch. Of the lot, 231,664 trucks are in the U.S., and 29,953 are in Canada. The Ford recall number is 19S48.  The second recall is much smaller, involving fewer than 4,000 vehicles. In certain 2020 Explorers and Aviators with 3.0-liter engines, Ford says, "The convolute protective sleeve on the liquid fuel line is not long enough, which may allow for potential hard contact with the convolute-protected vapor fuel line. Over time, with vibration and engine roll, hard contact between the two fuel lines could cause the convolute on the vapor fuel line to rub through the plastic liquid fuel line." If that happens, it could be a fire risk and hazardous for drivers and passengers. Only 35 of those SUVs are in Canada, and the rest are in the United States. Dealers will fix the problem by replacing the defective convolute with a full-length piece and tying it down with a strap. The recall reference number for the Aviators and Explorers is 19S49. The recall adds to what has otherwise been a rocky early production phase for the new Explorers and Aviators.

2020 Ford Explorer nabs IIHS Top Safety Pick+ rating after updates

The 2020 Ford Explorer has been named a Top Safety Pick+ by the Insurance Institute for Highway Safety, the agency's best rating. The redesigned Explorer initially fell short of that mark, however, only making the grade after Ford introduced a running change to the vehicle's design starting in May 2020 — a change made to the 2020 Lincoln Aviator as well. To achieve a Top Safety Pick+ award, a vehicle must have a Good performance rating in all six of the agency's crash tests. It also must have Acceptable or better ratings for all of its available headlamps and must earn Advanced or Superior ratings for its automated collision avoidance systems in tests of their performance against pedestrians and other vehicles. The 2020 Explorer initially achieved only an Acceptable performance in the IIHS's driver's-side small-overlap crash test, as the agency found a risk of injury to the driver's left foot due to intrusion into the footwell. Ford subsequently modified the design of the front subframe in a running change to Explorers and to Lincoln Aviators built after May 2020. The modified Explorer was re-tested, and this time the model achieved a Good performance in the driver's small-overlap test. That, combined with a Superior performance in both tests of the standard collision-avoidance system plus Acceptable ratings for both headlight systems, pushed the 2020 Explorer over the goal line to Top Safety Pick+. The Aviator, which shares the Explorer's platform, has received the same modification and achieves the same crashworthiness ratings. However, its standard headlights are judged Marginal, and therefore the 2020 Aviator achieves only the Top Safety Pick rating (even though its optional curve-adaptive LED headlights are judged Good). Related Video:

Ford announces four recalls, 1.4M vehicles affected

Ford is taking a bit of the spotlight away from General Motors, announcing a major group of recall campaigns, covering a total of 1.4 million vehicles built between 2006 and 2013.
Let's start with the big one, which covers the Ford Escape, Mercury Mariner and, according to The Detroit News, Ford-built Mazda Tribute CUVs. 915,216 vehicles are covered, all of which were built in model years 2008 to 2011. 736,000 vehicles are in the US, while Canada then Mexico make up the vast majority of the remainder. The problem is due to an issue with the torque sensor in the steering column, which could lead to sudden power steering failure. Manual steering would still be available, though.
"Dealers will perform one of three service fixes, depending upon what diagnostic codes are shown when the vehicle is taken to the dealer," Ford spokeswoman Kelli Felker wrote to Autoblog in an email. "They will either update software for the power steering control module and the instrument cluster module; replace the torque sensor; or replace the steering column, which includes upgraded power steering control module software."