2013 Honda Crosstour Ex-l on 2040-cars

Auto blog

Brand new cars are being sold with defective Takata airbags

If you just bought a 2016 Audi TT, 2017 Audi R8, 2016–17 Mitsubishi i-MiEV, or 2016 Volkswagen CC, we have some unsettling news for you. A report provided to a US Senate committee that oversees the US National Highway Traffic Safety Administration (NHTSA) and reported on by Automotive News claims these vehicles were sold with defective Takata airbags. And it gets worse. Toyota and FCA are called out in the report for continuing to build vehicles that will need to be recalled down the line for the same issue. That's not all. The report also states that of the airbags that have been replaced already in the Takata recall campaign, 2.1 million will need to eventually be replaced again. They don't have the drying agent that prevents the degradation of the ammonium nitrate, which can lead to explosions that can destroy the airbag housing and propel metal fragments at occupants. So these airbags are out there already. We're not done yet. There's also a stockpile of about 580,000 airbags waiting to be installed in cars coming in to have their defective airbags replaced. These 580k airbags also don't have the drying agent. They'll need to be replaced down the road, too. A new vehicle with a defective Takata airbag should be safe to drive, but that margin of safety decreases with time. If all this has you spinning around in a frustrated, agitated mess, there's a silver lining that is better than it sounds. So take a breath, run your fingers through your hair, and read on. Our best evidence right now demonstrates that defective Takata airbags – those without the drying agent that prevents humidity from degrading the ammonium nitrate propellant – aren't dangerous yet. It takes a long period of time combined with high humidity for them to reach the point where they can rupture their housing and cause serious injury. It's a matter of years, not days. So a new vehicle with a defective Takata airbag should be safe to drive, but that margin of safety decreases with time – and six years seems to be about as early as the degradation happens in the worst possible scenario. All this is small comfort for the millions of people who just realized their brand-new car has a time bomb installed in the wheel or dashboard, or the owners who waited patiently to have their airbags replaced only to discover that the new airbag is probably defective in the same way (although newer and safer!) as the old one.

4.5 million Hondas, Acuras are being recalled worldwide to fix a fuel pump defect

Honda is recalling more than 4.5 million cars worldwide because of a fuel pump problem that could lead to engine failure or stalling in traffic, which could cause an accident. The recall includes 2.54 million vehicles in the United States. The automaker had previously recalled 628,000 U.S. vehicles in 2021 and 136,000 in 2020 for the same issue. Honda issued recalls over the same issue earlier this month in China and Japan. National Highway Traffic Safety Administration recall documents say the impellers inside fuel pumps of 2017-2020 Hondas and Acuras were improperly made, meaning they “can deform and interfere with the fuel pump body” over time. This could prevent the engine from starting, or can cause a stall while driving, which depending on the situation in traffic, could be dangerous. Fortunately, Honda says it hasn't received any reports of crashes or injuries. To remedy the problem, Honda will replace the in-tank fuel pumps, at no cost to owners, in the entire U.S. recall population of 2,539,902 vehicles, though the defect may be present in only 1 percent of those cars. Because of the size of the recall, repairs will be done in phases, with first owners receiving notification letters in February. Dealer notifications began this week. “Countermeasure replacement parts are not available in sufficient quantities for all recalled vehicles at the time of this announcement, and American Honda intends to notify vehicle owners in stages," Honda wrote. Meanwhile, owners wishing to confirm that their vehicle is included can enter their VIN at the NHTSA recall site or at American Honda's and Acura's recall platforms.  NHTSA's campaign number for the recall is 23V858000. Honda's numbers for this recall are KGC and KGD. Owners may also contact Honda customer service by phone: 1-888-234-2138.

As US exports top 2 million, is America becoming the world's source of cheap cars?

North American auto production is booming with 2014 figures just shy of the of the 17.3-million vehicle record set in 2000. With more models being built on the continent, even more are being shipped overseas. Factories in the US exported 2.1 million cars last year – the highest number ever. About half of those went to Canada and Mexico, but more than ever have been heading to places like the Middle East and China. The upswing comes in part from from after-effects from the Great Recession, according to The Wall Street Journal. With a weak dollar and lower production costs after the financial crisis, building vehicles in the US was relatively cheaper and more competitive in the world. At the same time buyers around the world are going crazy for crossovers. According to the WSJ, BMW and Mercedes-Benz are already exporting the majority of their US production of these models overseas. Both automakers have also announced investments to expand production further here to send more vehicles abroad. Even Honda has been shipping more models out of the country than it imported here. There is a concern this international strength could start slowing because the dollar is strengthening against other currencies, though it's too early to know what the actual effect of this could be, according to the WSJ. "Of course, we closely watch currency exchange, but we don't make changes in production or allocation based on temporary fluctuations in the exchange rate," Ford North American boss Joe Hinrichs told the newspaper. Related Video: News Source: The Wall Street Journal - sub. req.Image Credit: BMW Plants/Manufacturing BMW Ford Honda Mercedes-Benz exports us auto production